| Most common failures | No# failures |
|---|
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Headlamp aim out of alignment | 3 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Brake pipe excessively corroded | 2 |
| Indicator tell tale inoperative |1.4.A.2a| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Registration plate lamp issues | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Registration plate issues | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Brakes imbalanced across an axle | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Windscreen washer not working | 1 |
| Position lamp not working all on rear either interactive or not working... or not a matched pair... upper and lower.. (4.2.1 (a) (ii)) | 1 |
| Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength cross member by front spring mount.. front and rear of member. (5.3.6 (a) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced step/inner sill (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced step/inner sill (6.1.1 (c) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outrigger behind front step (6.1.1 (c) (i)) | 1 |
| Brake hose excessively deteriorated | 1 |
| Oil leaking excessively from engine from fuel pump...? appears to be repaired with silicon sealant (8.4.1 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |