| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 16 |
| Rear parking brake recording little or no effort | 7 |
| Brake pipe excessively corroded | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Rear brake binding | 5 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 5 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Registration plate lamp issues | 4 |
| Registration plate issues | 4 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Offside Front coil spring fractured |2.4.C.1a| | 2 |
| Nearside Front coil spring broken |2.4.C.1a| | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 2 |
| Offside Front coil spring broken |2.4.C.1a| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Power steering malfunctioning steering very stiff and not returning properly |2.1.5 |a|| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Drivers view of the road through the swept area of the windscreen materially affected by an obstruction multiple item hanging from interior mirror (3.1 (a) (ii)) | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Headlamp aim not tested Due to headlamp lens being seriously defective (4.1.2 (b)) | 1 |
| Rear Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Engine MIL inoperative or indicates a malfunction eml light on (8.2.1.2 (h)) | 1 |
| Headlamp levelling device inoperative Front sensor linkage broken (4.1.5 (a)) | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt lower front (5.3.4 (b) (ii)) | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Brakes imbalanced across an axle | 1 |
| Steering locking device insecure |2.2.C.1g| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Brake hose twisted n/s rear |3.6.B.4c| | 1 |
| Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Indicator switch faulty indicator not staying on when offside applied |1.4.A.1| | 1 |
| Offside Front Lower Radius arm has excessive play in a ball joint rear 1 |2.4.G.2| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Windscreen washer not working | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Windscreen wiper not working |3.4 |a|| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint rear arm |2.4.G.2| | 1 |
| Nearside Front Suspension arm synthetic bush deteriorated resulting in excessive movement front arm |2.4.G.2| | 1 |
| Offside Front Suspension arm synthetic bush deteriorated resulting in excessive movement front arm |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint also split |2.4.G.2| | 1 |
| Central Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Headlamp cleaning device inoperative |1.7.2| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Inner Track rod end loose LOCK NUT TO TRACK ROD END MARKED YELLOW |2.2.B.1d| | 1 |