| Most common failures | No# failures |
|---|
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 27 |
| Windscreen wiper does not clear the windscreen effectively | 18 |
| Headlamp aim out of alignment | 15 |
| Brakes imbalanced across an axle | 12 |
| Brake hose excessively deteriorated | 11 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 11 |
| Registration plate lamp issues | 11 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 6 |
| Nearside Headlamp not working on main beam |1.7.5a| | 6 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Rear brake binding | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 4 |
| Rear Exhaust system not adequately supported |7.1.1| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Rear Mechanical brake component has restricted free movement | 3 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 3 |
| Brake pipe excessively corroded | 3 |
| Hazard warning switch faulty |1.4.B.1d| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 3 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 3 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Rear Exhaust mounting missing |7.1.1b| | 3 |
| Nearside Rear Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Registration plate issues | 2 |
| Rear brake application uneven | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 2 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
| Offside Front coil spring cracked |2.4.C.1a| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| An item not tested |Manual| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 2 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Headlamp reflector seriously defective |4.1.1 |b| |ii|| | 1 |
| Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Power steering component leaking steering box (2.1.5 (a)) | 1 |
| Front Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Centre Steering damper leaking oil |2.2.C.1f| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch/sill |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch/sill |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail / spring mounting |5.3.6 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail / spring mounting |5.3.6 |a| |i|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor seat mounting |5.3.6 |a| |i|| | 1 |
| Offside Front Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Direction indicator incorrect colour lens damaged |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength as marked (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength as marked (5.3.6 (a) (i)) | 1 |
| Exhaust fumes causing a danger to health of persons on board |6.1.2 |b| |ii|| | 1 |
| Front Exhaust system not adequately supported bracket broken |7.1.1| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner seal panel |6.1.B.2| | 1 |
| Nearside Rear Fuel pipe leaking |7.2.3| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Hazard warning lamps inoperative all |1.4.B.1b| | 1 |
| Centre Brake linkage locking device insecure |3.5.1l| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Inner Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Front Outer Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Steering box has excessive free play detected at the steering wheel |steering box fitted| |2.3 |a| |i|| | 1 |
| Central Rear Seat belt not functioning as intended |7.1.2 |c|| | 1 |
| Offside Front Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Front Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Windscreen wiper blade insecure | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Nearside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Offside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded floor/ sill |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded floor/ sill |5.2.6| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor near suspension arm fixing |5.3.6 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing and bulk head |5.3.6 |a| |i|| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Inner Front front brake binding |3.7.B.1| | 1 |
| Statutory seat belt missing |5.1.1| | 1 |
| Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
| Offside rear brake grabbing severely |3.7.A.5b| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |