| Most common failures | No# failures |
|---|
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 15 |
| Headlamp aim out of alignment | 14 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 14 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 11 |
| Registration plate issues | 9 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Brake pipe excessively corroded | 5 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 5 |
| Registration plate lamp issues | 5 |
| Horn not working |1.6.2a| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 4 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Rear brake binding | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 3 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 3 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Brake hose excessively deteriorated | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Rear fog lamp tell tale missing |1.3.1b| | 2 |
| Battery insecure |1.9.1| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Rear fog lamp missing |1.3.2a| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Rear Rear fog lamp missing |1.3.2a| | 2 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 2 |
| Brake performance not tested leaking caliper |1.2.1 |g|| | 1 |
| Offside Front Hydraulic brake calliper leaking and braking performance affected |1.1.16 |b| |ii|| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front brake application uneven | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.2.1 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Central Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn Lower arm outer bush marked yellow (5.3.4 (a) (i)) | 1 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced Hole in inner sill/floor (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| All position lamps adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Stop lamp(s) remains on when the brakes are released (4.3.2 (a) (iii)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Front position lamp|s| missing |1.1.A.3a| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Rear Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Side repeater flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Front Direction indicator missing |1.4.A.2b| | 1 |
| Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Front Body has a projection caused by damage |6.1.C.1| | 1 |
| Rear Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Offside Rear Inner Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction |3.1 |a| |ii|| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Electrical wiring insecure |1.9.2a| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Service brake juddering severely |3.7.C.2| | 1 |
| Nearside Rear All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear Service brake excessively binding both (1.2.1 (f)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Wheel nut|s| missing |4.2.A.1e| | 1 |
| Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension component missing ball joint locking device missing (5.3.3 (a) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Front Steering locking device missing track rod end (2.1.3 (d)) | 1 |
| Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Offside Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Exhaust emits clearly visible black smoke during acceleration |7.3.A.2c| | 1 |
| Windscreen has damage | 1 |