| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 22 |
| Headlamp aim out of alignment | 17 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 13 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 11 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 10 |
| Registration plate lamp issues | 9 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Brake pipe excessively corroded | 8 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Rear parking brake recording little or no effort | 7 |
| Offside Rear fog lamp not working |1.3.2b| | 7 |
| Registration plate issues | 7 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Service brake: efficiency below requirements |3.7.B.7| | 6 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 4 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 3 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Rear brake binding | 3 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 3 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 3 |
| Front brake application uneven | 3 |
| Horn not working |1.6.2a| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Battery insecure |1.9.1| | 2 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 2 |
| Exhaust emissions hydrocarbon content excessive |8.2.1.2 |b|| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 2 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Exhaust mounting missing |7.1.1b| | 2 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
| Service brake: efficiency below requirements |3.7.D.4| | 2 |
| Parking brake: efficiency below requirements |3.7.D.4| | 2 |
| Fuel system component insecure |7.2.1| | 2 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Fuel pipe insecure |7.2.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced A post/windscreen frame |6.1.1 |c| |i|| | 1 |
| Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering Steering idler about to become detached |6.1.1 |c| |ii|| | 1 |
| Nearside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Rear Tie bar/rod insecure |2.4.G.1| | 1 |
| Nearside Front Steering component mounting prescribed area is inadequately repaired not continuously welded (2.1.2 (e) (i)) | 1 |
| Offside Front Steering component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected steering box (2.1.2 (e) (ii)) | 1 |
| Nearside Front Passengers seat with a defective structure floor corroded (6.2.6 (a) (i)) | 1 |
| Nearside Front Fuel pipe leaking under floor fuel pipe leaking at joint (6.1.3 (b) (i)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Windscreen wiper not working |3.4 |a|| | 1 |
| Offside Windscreen wiper not working |3.4 |a|| | 1 |
| Offside Obligatory mirror missing |3.3 |a|| | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Inner sill/floor pan. |6.1.1 |c| |i|| | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Inner sill/floor pan. |6.1.1 |c| |i|| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded Chassis leg |2.4.A.3| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front Upper Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Front position lamp|s| missing |1.1.A.3a| | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded inner wing and inner wheel arch |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded floor and inner wheel arch |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded floor and inner wheel arch |2.4.A.3| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner wheel arch |2.4.A.3| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
| Brake servo defective or ineffective Leaking brake fluid from bottom (Excess corrosion) (1.1.10 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded Inner sill. |2.4.A.3| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear front brake binding |3.7.B.1| | 1 |
| Offside Rear front brake binding |3.7.B.1| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect WEAK (4.1.2 (c)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Centre Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Steering arm damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Rear Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Oil leaking continuously from engine posing a serious risk to road safety (8.4.1 (a) (ii)) | 1 |
| Service brake excessively binding o.s.f (1.2.1 (f)) | 1 |
| Windscreen wiper blade insecure | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Rear Wheel bolt|s| loose |4.2.A.1e| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Anti-roll bar linkage cracked |2.4.G.1| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Steering locking device missing ALL split pins missing from front steering |2.2.C.1g| | 1 |
| Braking system leaking rear pipe by fuel filter |3.6.A.1| | 1 |
| Seat belt anchorage prescribed area is excessively corroded ns floor pan |5.2.6| | 1 |
| Shock absorber insecure nsf and osf |2.7.2b| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Rear fog lamp insecure |1.3.2a| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Rear Electrical wiring insecure |1.9.2a| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear Anti-roll bar linkage missing |2.4.G.1| | 1 |
| Emissions not tested due to exhaust blow |7.3.A.1| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Rear Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has an inadequate repair which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) (2.3 (a) (i)) | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |