| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 68 |
| Parking brake: efficiency below requirements |3.7.B.7| | 51 |
| Registration plate issues | 40 |
| Windscreen wiper does not clear the windscreen effectively | 27 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 26 |
| Offside Steering rack gaiter split |2.2.D.2d| | 20 |
| Brake pipe excessively corroded | 18 |
| Rear parking brake recording little or no effort | 17 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 13 |
| Parking brake lever has no reserve travel |3.1.6b| | 12 |
| Registration plate lamp issues | 9 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 9 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 8 |
| Brakes imbalanced across an axle | 8 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 6 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 5 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 5 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 5 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 3 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Nearside Engine mounting bracket damaged or deteriorated resulting in excessive movement |6.1.8 |a| |i|| | 2 |
| Offside Engine mounting bracket damaged or deteriorated resulting in excessive movement |6.1.8 |a| |i|| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Parking brake lever defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 2 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 2 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 2 |
| Windscreen wiper blade insecure | 2 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Front brake excessively fluctuating | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Brake pipe inadequately clipped |3.6.B.1| | 2 |
| Front brake application uneven | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Stop lamp|s| switch with a delay in operation |4.3.2 |a| |ii|| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Nearside Suspension component mounting prescribed area is inadequately repaired Sill Area |5.3.6 |a| |i|| | 1 |
| Offside Suspension component mounting prescribed area is inadequately repaired Sill Area |5.3.6 |a| |i|| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Hazard warning switch inoperative unable to locate (4.4.2 (a) (ii)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Offside Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Nearside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Nearside Brake pipe at imminent risk of failure or fracture LEAKING (1.1.11 (a)) | 1 |
| Nearside Rear Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear Upper Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Parking brake lever ratchet not holding correctly (1.1.6 (a)) | 1 |
| Boot lid cannot be secured in the closed position (6.2.1 (e)) | 1 |
| Nearside Rear Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Power steering ram leaking (2.1.5 (a)) | 1 |
| Nearside Inner Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Inner Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Rear Hydraulic fluid leaking excessively (8.4.1 (a) (i)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Parking brake lever releases when knocked |3.1.6a| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt split (2.1.3 (g) (ii)) | 1 |
| Offside Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Front Direction indicator incorrect colour both |1.4.A.2f| | 1 |
| Rear Direction indicator incorrect colour both |1.4.A.2f| | 1 |
| Nearside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Offside Front Electrical wiring insecure wheel area |1.9.2a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Brake pipe likely to become detached or damaged At N/S fouling hand brake cable (1.1.11 (d) (ii)) | 1 |
| Electronic stability control switch not functioning correctly (7.12 (d)) | 1 |
| Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced jacking point/inner sill (6.1.1 (c) (i)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn upper arm front bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Integral body structure strengthening plate or fastening so insecure that structural rigidity is seriously reduced underside outer sill to floor pan holed to excess. (6.1.1 (b) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Rear Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Parking brake lever inoperative release button sticks not allowing locking of parking brake (1.1.6 (d)) | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Lower Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Rear brake binding | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Rear Brake pipe leaking on an air braking system (1.1.11 (b) (i)) | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt split |2.1.3 |g| |ii|| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt split |2.1.3 |g| |ii|| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| flickers when tapped lightly by hand |1.1.4c| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Parking brake lever is not capable of being maintained in operation by direct mechanical action only (1.1.6 (f)) | 1 |
| Nearside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Nearside Rear Direction indicator incorrect colour white light |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour white light |1.4.A.2f| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Road wheel cracked inner rim |4.2.A.1a| | 1 |
| Bootlid cannot be secured in the closed position |6.4.1| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Windscreen wiper not working Both (3.4 (a)) | 1 |
| Windscreen washer not working | 1 |
| Rear fog lamp switch not operating in accordance with the requirements (4.5.3 (a)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Upper Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Power steering component leaking Radiator |2.1.5 |a|| | 1 |
| Offside Rear Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
| Nearside Suspension component mounting prescribed area is inadequately repaired sill area |5.3.6 |a| |i|| | 1 |
| Offside Suspension component mounting prescribed area is inadequately repaired sill area |5.3.6 |a| |i|| | 1 |
| Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
| Centre Rear Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Offside Front Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Nearside Rear Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Offside Rear Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt pin bush dust cover. (5.3.4 (b) (ii)) | 1 |
| Offside Rear Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt pin bush dust cover. (5.3.4 (b) (ii)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |