| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 58 |
| Headlamp aim out of alignment | 51 |
| Windscreen wiper does not clear the windscreen effectively | 41 |
| Registration plate issues | 37 |
| Rear parking brake recording little or no effort | 25 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 13 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 8 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 8 |
| Anti-lock braking system warning lamp indicates an ABS fault | 8 |
| Windscreen washer not working | 6 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 6 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 5 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 5 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 5 |
| Offside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 5 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 5 |
| Brakes imbalanced across an axle | 5 |
| Offside Rear Shock absorbers has a serious fluid leak | 4 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 4 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 4 |
| Offside Rear coil spring broken |2.4.C.1a| | 4 |
| Nearside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 4 |
| Nearside Front coil spring broken |2.4.C.1a| | 3 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 3 |
| Electronic parking brake warning indicates a malfunction |1.1.6 |e|| | 3 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Registration plate lamp issues | 2 |
| Offside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 2 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 2 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Electronic parking brake control inoperative (1.1.6 (d)) | 2 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Front brake application uneven | 2 |
| Front brake excessively fluctuating | 2 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Nearside Headlamp cleaning device for LED or HID headlamp inoperative |4.1.6 |a| |ii|| | 2 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Front Road wheel cracked |4.2.A.1a| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Central Rear Seat belt damaged |7.1.2 |b| |i|| | 1 |
| Offside Rear Parking brake inoperative on one side below efficiency (1.4.1 (a)) | 1 |
| Nearside Front Road wheel cracked |4.2.A.1a| | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Front Service brake lagging in operation |1.2.1 |d|| | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Obligatory mirror seriously obscured affecting the rear view |8.1.2a| | 1 |
| Nearside Front Upper Suspension arm pin or bush likely to become detached arm (5.3.4 (a) (ii)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn arm (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Inner Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn tie bar (5.3.4 (a) (i)) | 1 |
| Rear brake application uneven | 1 |
| Suspension component mounting prescribed area is excessively corroded offside front inner chassis/body |2.4.A.3| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Front Upper Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Electronic parking brake warning indicates a malfunction |3.1.7| | 1 |
| Electronic parking brake control defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Front Lower Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
| Electronic parking brake control defective so that it cannot be satisfactorily operated |1.1.6 |d|| | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn front bush (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Undertray insecure (8.1.1 (b) (i)) | 1 |
| Nearside Front Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn tie bar/ arm excessive play inner (5.3.4 (a) (i)) | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Upper Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Windscreen wiper not working |3.4 |a|| | 1 |
| Offside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake: efficiency below requirements (3.7.B.7) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front Shock absorber has an excessively worn bush (2.7.4) | 1 |
| Offside Front Shock absorber has an excessively worn bush (2.7.4) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength subframe between arm mounts (5.3.6 (a) (i)) | 1 |
| Drivers airbag obviously inoperative (7.1.5 (c)) | 1 |
| Nearside Rear Road wheel fractured (5.2.2 (a)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt Insecure. |2.1.3 |g| |ii|| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Front Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Nearside Front Upper Suspension arm attachment bracket/mounting likely to become detached Ball joint (5.3.3 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Road wheel fractured (5.2.2 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect kick off (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect kick off (4.1.2 (c)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn top arm front bush (5.3.4 (a) (i)) | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded in between upper suspension arm mounts |2.4.A.3| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Nearside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn top wishbone (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn top wishbone (5.3.4 (a) (i)) | 1 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded suspension arm area |2.4.A.3| | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Brake insecure caliper pin missing, not securing pads (1.1.21 (c)) | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering front subframe both sides (6.1.1 (c) (ii)) | 1 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Sub-frame corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Sub-frame corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Windscreen has damage | 1 |
| Hand operated control valve malfunctioning |3.2.2c| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Brake has no servo assistance |3.3.B.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Nearside Rear Brake hose excessively damaged (1.1.12 (b) (ii)) | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Front Inner Sub-frame corroded to the extent that the rigidity of the assembly is significantly reduced both (near catalysts) (6.1.1 (c) (i)) | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component ball joint excessively worn camber or toe adjusting arm ? (5.3.4 (a) (i)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Electronic parking brake warning indicates a malfunction (1.1.6 (e)) | 1 |
| Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Lower Macpherson strut pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Macpherson strut pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage insecurely attached |5.3.3 |a| |i|| | 1 |
| Parking brake inoperative on one side offside rear (1.4.1 (a)) | 1 |
| Parking brake inoperative on one side nearside rear (1.4.1 (a)) | 1 |
| Offside Headlamp cleaning device for LED or HID headlamp inoperative |4.1.6 |a| |ii|| | 1 |
| Bonnet primary retaining device ineffective bonnet shockers |3.1 |c|| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Suspension rod ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn shocker support bush (5.3.4 (a) (i)) | 1 |
| Front Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Parking |secondary brake| on a single line braking system has no recorded effort at a wheel |1.3.1 |a| |ii|| | 1 |
| Offside Rear Parking |secondary brake| on a single line braking system has no recorded effort at a wheel |1.3.1 |a| |ii|| | 1 |