| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 75 |
| Registration plate issues | 48 |
| Windscreen wiper does not clear the windscreen effectively | 37 |
| Parking brake: efficiency below requirements |3.7.B.7| | 18 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 16 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 11 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 11 |
| Anti-lock braking system warning lamp indicates an ABS fault | 10 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 8 |
| Offside Front coil spring broken |2.4.C.1a| | 5 |
| Windscreen washer not working | 5 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 5 |
| Nearside Front coil spring broken |2.4.C.1a| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 4 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 4 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
| Nearside Rear Shock absorbers has a serious fluid leak | 3 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 3 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Brake hose damaged | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Rear fog lamp switch inoperative (4.5.3 (a) (ii)) | 2 |
| Offside Front Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 2 |
| Nearside Reversing lamp inoperative (4.6.1 (a)) | 2 |
| Electronic parking brake control inoperative (1.1.6 (d)) | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp cleaning device for LED or HID headlamp inoperative |4.1.6 |a| |ii|| | 1 |
| Offside Headlamp cleaning device for LED or HID headlamp inoperative |4.1.6 |a| |ii|| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Headlamp cleaning device for LED or HID headlamp inoperative Not cleaning headlamp |4.1.6 |a| |ii|| | 1 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Road wheel badly distorted leaking air |5.2.2 |c| |i|| | 1 |
| Nearside Headlamp cleaning device obviously defective |1.7.2| | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Registration plate lamp issues | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Electronic parking brake warning indicates a malfunction |3.1.7| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Nearside Rear Exhaust system insecure |6.1.2 |a|| | 1 |
| Offside Exhaust system insecure |6.1.2 |a|| | 1 |
| Windscreen has damage | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
| Offside Front Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Headlamp levelling device obviously defective link arm corroded and fractured |1.7.2| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Power steering ram|s| leaking from a failed joint |2.3.3b| | 1 |
| Rear brake application uneven | 1 |
| Rear brake binding | 1 |
| Body has a sharp edge caused by damage FRONT REG PLATE |6.1.C.1| | 1 |
| Brakes imbalanced across an axle | 1 |
| Brake pipe excessively damaged two main |3.6.B.2c| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Emissions not tested no fuel. (8.2.1.2 (d)) | 1 |
| Offside Rear Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Nearside Front Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Nearside Front Position lamp not working started working during test, suspect deteriorated light source or connection (4.2.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (1.7.5a) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Central Front Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Front Coil spring fractured or broken lower coil broken. (5.3.1 (b) (i)) | 1 |
| Brake master cylinder insecure (1.1.10 (c)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn inner front bush (5.3.4 (a) (i)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Front Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Coil spring corroded so that its cross sectional area is reduced and seriously weakened (5.3.1 (b) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Road wheel badly distorted (5.2.2 (c) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Windscreen in an unacceptable condition (3.2 (c) (i)) | 1 |
| Coil spring fractured or broken Offside front (5.3.1 (b) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Exhaust system insecure clamp broken away. (6.1.2 (a)) | 1 |
| Nearside Rear Exhaust system insecure clamp broken away. (6.1.2 (a)) | 1 |
| Front Drive belt excessively worn pulleys also slightly damaged (6.1.7 (c) (i)) | 1 |
| Electronic parking brake control defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
| Parking brake efficiency below requirements n/s & o/s (1.4.2 (a) (i)) | 1 |
| Rear Boot lid cannot be secured in the closed position (6.2.1 (e)) | 1 |
| Front Inner Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Rear Headlamp levelling device inoperative Level sensor linkage broken (4.1.5 (a)) | 1 |
| Offside Rear Inner Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Headlamp cleaning device for LED or HID headlamp inoperative does not clean headlight (4.1.6 (a) (ii)) | 1 |
| Electronic parking brake warning indicates a malfunction (1.1.6 (e)) | 1 |
| Parking brake inoperative on one side both sides (1.4.1 (a)) | 1 |
| Nearside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Headlamp cleaning device for LED or HID headlamp inoperative washer jet missing (4.1.6 (a) (ii)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Front Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn loose (5.3.4 (a) (i)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Front Sub-frame corroded and seriously weakened near upper suspension arm mounting (5.3.3 (b) (i)) | 1 |
| Nearside Rear Exhaust silencer insecure clamp missing (8.1.1 (b) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |