| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 20 |
| Headlamp aim out of alignment | 9 |
| Registration plate issues | 6 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Registration plate lamp issues | 5 |
| Rear parking brake recording little or no effort | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Horn not working |1.6.2a| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 2 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| All position lamps not working |4.2.1 |a|| | 1 |
| Offside Rear Coil spring not correctly located |2.4.C.2| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Macpherson strut has excessive play in the sliding bush or gland |2.5.B.1b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Brake pipe excessively corroded | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Position lamp switch insecure |1.1.A.1| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Direction indicator not working |1.4.A.2c| | 1 |
| Centre Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Exhaust has a part missing |7.1.1a| | 1 |
| Offside Exhaust has a part missing |7.1.1a| | 1 |
| Offside Front Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| An item not tested |Manual| | 1 |
| Offside Inner Rear Fuel hose leaking |7.2.3| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Parking brake lever pawl spring does not push the pawl positively into the ratchet teeth |3.1.5| | 1 |
| Brake cable locking device missing |3.5.1l| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Brake hose has insufficient room to move | 1 |
| Emissions not tested |7.0| | 1 |
| Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Upper Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Nearside Rear Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Rear Outer Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced corrosion x2 (7.1.1 (a) (i)) | 1 |
| Offside Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Behind Front Wheel (6.1.1 (c) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Fuel hose leaking (6.1.3 (b) (i)) | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |