| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 27 |
| Brake pipe excessively corroded | 21 |
| Rear parking brake recording little or no effort | 10 |
| Rear brake binding | 10 |
| Registration plate lamp issues | 10 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 9 |
| Brakes imbalanced across an axle | 7 |
| Front brake application uneven | 7 |
| Registration plate issues | 6 |
| Anti-lock braking system warning lamp indicates an ABS fault | 6 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Brake hose has insufficient room to move | 4 |
| Nearside front brake binding |3.7.B.1| | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Nearside Side repeater not working |1.4.A.2c| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Steering rack insecure |2.2.B.1a| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Battery insecure |1.9.1| | 2 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Windscreen washer not working | 2 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Nearside Front Headlamp aim not tested |4.1.2 |b|| | 1 |
| Offside Front Headlamp aim not tested |4.1.2 |b|| | 1 |
| Offside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Rear Exhaust has a major leak of exhaust gases box |7.1.2| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| brake caliper has restricted free movement |3.5.1k| | 1 |
| Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Rear reflector not red in colour |1.5.1d| | 1 |
| Offside Rear reflector not red in colour |1.5.1d| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Side repeater incomplete |1.5.A1b| | 1 |
| Offside Rear brake disc has restricted free movement |3.5.1j| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake pump/compressor insecure |3.6.F.1| | 1 |
| Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Front Headlamp missing does not pop up |1.7.3| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Direction indicator has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
| Nearside Front Direction indicator has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
| Nearside Fuel cap/sealing device missing |7.2.4a| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Electrical wiring inadequately supported |1.9.2a| | 1 |
| Nearside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Brake hose damaged | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside front brakes release unevenly |3.7.B.4| | 1 |
| Nearside Rear An item not tested |Manual| | 1 |
| Brake servo damaged and function impaired |3.6.A.2c| | 1 |
| Front An item not tested |Manual| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front Obligatory mirror insecure |8.1.1| | 1 |
| Anti-lock braking system warning lamp sequence is incorrect |3.4.1d| | 1 |
| Offside Rear Braking system leaking Calliper ? |3.6.A.1| | 1 |
| Nearside Rear Suspension arm insecure |2.4.G.1| | 1 |
| Offside Rear Suspension arm insecure |2.4.G.1| | 1 |
| Nearside Front Suspension arm insecure |2.4.G.1| | 1 |
| Offside Front Suspension arm insecure |2.4.G.1| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Side repeater not working |1.4.A.2c| | 1 |
| Nearside Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Offside Front Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Front Direction indicator not working wing (4.4.1 (a) (ii)) | 1 |
| Nearside Front Headlamp missing (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp missing (4.1.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp switch inoperative (4.5.3 (a) (ii)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Power steering malfunctioning (2.1.5 (a)) | 1 |
| Front Brake pipe leaking on an air braking system (1.1.11 (b) (i)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Front Hydraulic brake calliper insecurely mounted lower bolt missing (1.1.16 (c) (i)) | 1 |
| Front Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Road wheel more than one fixing missing all 4 wheels have fixing missing (5.2.1 (a) (ii)) | 1 |
| Central Rear Oil leaking excessively from transmission diff (8.4.1 (a) (i)) | 1 |