| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 24 |
| Registration plate lamp issues | 17 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 10 |
| Offside Rear fog lamp not working |1.3.2b| | 10 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 10 |
| Brake pipe excessively corroded | 9 |
| Offside Steering rack gaiter split |2.2.D.2d| | 9 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 8 |
| Rear fog lamp tell tale not working |1.3.1b| | 8 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 8 |
| Brakes imbalanced across an axle | 6 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 6 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 5 |
| Rear brake binding | 5 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 4 |
| Horn not working |1.6.2a| | 4 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 4 |
| Rear fog lamp switch faulty |1.3.1a| | 4 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 4 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Hazard warning switch faulty |1.4.B.1d| | 3 |
| Registration plate issues | 3 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 3 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Windscreen washer not working | 3 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 3 |
| Bonnet cannot be secured in the closed position |8.4.1| | 2 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Rear An item not tested |Manual| | 2 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Steering rack insecure |2.2.B.1a| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 2 |
| Offside Rear coil spring fractured |2.4.C.1a| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Power steering pump leaking from a failed seal |2.3.3b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
| Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Offside Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Centre Rear Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Brake vacuum build up too slow |3.3.E.6| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Brake pressure build up too slow |3.3.E.6| | 1 |
| Brake servo vacuum pipe collapsed |3.6.C.1b| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Steering column universal joint has excessive play |2.1.5| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Lower Steering column universal joint has excessive play |2.1.5| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Position lamp switch insecure |1.1.A.1| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Horn control missing |1.6.1| | 1 |
| Offside Front suspension has a suspension upper ball joint securing nut not locked |2.5.B.1a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Rear Drive shaft which forms part of the suspension coupling gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Nearside Front Headlamp aim not tested |4.1.2 |b|| | 1 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Front front brakes release unevenly |3.7.B.4| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Outer Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Outer Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Centre Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Exhaust system insecure |6.1.2 |a|| | 1 |
| Front brake application uneven | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Front Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust emits visible black smoke at idle |7.3.A.2b| | 1 |
| Offside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Nearside Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear fog lamp tell-tale not working |4.9.1 |a| |ii|| | 1 |
| Offside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Nearside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Battery insecure |1.9.1| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Brake pipe excessively chafed body mounts damaged allowing fouling/chafing of brake pipe |3.6.B.2c| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside Rear Exhaust mounting missing |7.1.1b| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Emissions not tested |7.0| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Nearside Front Steering rack insecure |2.2.B.1a| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Rear Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Rear Stop lamp not working x2 |1.2.1b| | 1 |
| Nearside Steering rack gaiter insecure gator |2.2.D.2d| | 1 |
| Offside Front Shock absorber has a serious fluid leak shock |2.7.3| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.3 |a|| | 1 |
| Nearside Front Wheel bearing play so excessive that directional control is impaired |5.1.3 |a| |ii|| | 1 |
| Exhaust emissions hydrocarbon content excessive |8.2.1.2 |b|| | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Rear Sub-frame attachment bracket/mounting insecure nut missing |5.3.3 |a| |i|| | 1 |
| Nearside Front Brake pipe connection leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Rear Brake pipe connection leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Brake servo defective or ineffective (1.1.10 (a) (i)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Emissions not tested overheated (8.2.1.2 (d)) | 1 |
| Oil leaking excessively from transmission rear differential (8.4.1 (a) (i)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Rear Exhaust system insecure backbox (6.1.2 (a)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Upper Suspension component ball joint dust cover no longer prevents the ingress of dirt Ball joint (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Suspension component ball joint dust cover no longer prevents the ingress of dirt Ball joint (5.3.4 (b) (ii)) | 1 |
| Offside Front Drivers door hinge insecure Heavily corroded (6.2.3 (c) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn ball joint moving inbetween arm (5.3.4 (a) (i)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Headlamp lens seriously defective not self raising (4.1.1 (b) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases Y piece (6.1.2 (a)) | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases backbox (6.1.2 (a)) | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Rear Brake cable insecure | 1 |
| Nearside Front Outer Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Front Exhaust has a major leak of exhaust gases Manifold to down pipe (6.1.2 (a)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Drivers seat insecure attachment bolts loose (6.2.5 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Upper Suspension rod pin or bush likely to become detached mounting nut/bolt loose (5.3.4 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Position lamp adversely affected by the operation of another lamp sidelight flashes when indicator is on (4.2.3 (c)) | 1 |