Most common failures | No# failures |
---|
Headlamp aim out of alignment | 40 |
Parking brake: efficiency below requirements |3.7.B.7| | 20 |
Registration plate lamp issues | 18 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 16 |
Rear parking brake recording little or no effort | 13 |
Windscreen wiper does not clear the windscreen effectively | 13 |
Offside Rear fog lamp not working |1.3.2b| | 10 |
Brakes imbalanced across an axle | 10 |
Rear brake application uneven | 10 |
Brake pipe excessively corroded | 7 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
Power steering component|s| leaking |2.3.3b| | 6 |
Offside Headlamp not working on dipped beam |1.7.5a| | 6 |
Service brake: efficiency below requirements |3.7.B.7| | 6 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 6 |
Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
Registration plate issues | 5 |
Centre Stop lamp not working |1.2.1b| | 5 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Offside Headlamp not working on main beam |1.7.5a| | 4 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 4 |
Nearside Front Shock absorber insecure |2.7.2b| | 4 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 4 |
Rear fog lamp tell tale not working |1.3.1b| | 4 |
Steering box insecure |2.2.B.1a| | 4 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Offside Stop lamp not working |1.2.1b| | 3 |
Hazard warning switch faulty |1.4.B.1d| | 3 |
Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 3 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
Windscreen has damage | 3 |
Offside Front Shock absorber insecure |2.7.2b| | 3 |
Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
Front Brake pipe inadequately clipped |3.6.B.1| | 3 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Side repeater not working |1.4.A.2c| | 2 |
Nearside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 2 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
Rear Rear fog lamp not working |1.3.2b| | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front Power steering component|s| leaking |2.3.3b| | 2 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
Horn sounds harsh or grating |1.6.2e| | 2 |
Nearside Headlamp insecure |1.7.3| | 2 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Windscreen wiper blade missing |8.2.2| | 2 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Stop lamp not working |1.2.1b| | 2 |
Intermediate drop arm insecure |2.2.B.1a| | 2 |
Offside Headlamp insecure |1.7.3| | 2 |
Offside Side repeater not working |1.4.A.2c| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Rear Stop lamp not working |1.2.1b| | 2 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Parking brake lever has no reserve travel |3.1.6b| | 2 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
Exhaust emits excessive dense blue smoke during acceleration |7.4.A2| | 1 |
Outer Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Lower Shock absorber insecure |2.7.2b| | 1 |
Offside Front Lower Shock absorber insecure |2.7.2b| | 1 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Horn not working |1.6.2a| | 1 |
Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Nearside Front front brake juddering severely |3.7.A.2b| | 1 |
Offside Front front brake juddering severely |3.7.A.2b| | 1 |
Brake master cylinder insecurely mounted |3.6.G.1a| | 1 |
Brake servo insecurely mounted |3.6.A.2a| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Offside Rear fog lamp tell tale not working |1.3.1b| | 1 |
Offside Front Fuel system component insecure |7.2.1| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front coil spring fractured |2.4.C.1a| | 1 |
Nearside Rear wheel cylinder securing device missing |3.5.1j| | 1 |
Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Outer Track rod end loose |2.2.B.1d| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Nearside Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Offside Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Nearside Rear Braking system leaking |3.6.A.1| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Inner Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Inner Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
Offside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Front Sub-frame cracked |2.4.G.1| | 1 |
Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Power steering inoperative |2.3.3a| | 1 |
Offside Front Lower Steering column shaft retaining device insecure |2.1.6| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Front Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Inner Front Ball joint has excessive play |2.2.B.1f| | 1 |
Position lamp switch insecure |1.1.A.1| | 1 |
Nearside Front Sub-frame cracked |2.4.G.1| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Steering column shaft locking device insecure |2.1.6| | 1 |
Nearside Front Battery insecure |1.9.1| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
Nearside Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
Brake servo vacuum pipe deteriorated |3.6.C.1b| | 1 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Inner Rear fog lamp not working |1.3.2b| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Rear Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Fuel pipe leaking |7.2.3| | 1 |
Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
Offside Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Offside Front Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
Offside Rear Shock absorbers has a serious fluid leak | 1 |
Electrical wiring insulation in such a condition there is an imminent risk of fire or formation of sparks Reverse light wiring not insulated (4.11 (c) (iii)) | 1 |
Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
Brake pedal pad not secure to the pedal |3.3.A.1c| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Offside Steering locking device missing |2.2.C.1g| | 1 |
Front Brake pipe excessively chafed |3.6.B.2c| | 1 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Centre Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Front Upper Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Brake cable has restricted free movement |3.5.1k| | 1 |
Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Nearside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Main beam `tell-tale` not working |1.7.4c| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Nearside Front Braking system leaking caliper |3.6.A.1| | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Steering column top mounting bracket insecure |2.1.2d| | 1 |
Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Centre Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Windscreen wiper blade insecure | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Offside Steering locking device insecure |2.2.C.1g| | 1 |
Offside Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Nearside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front brake caliper leaking |3.6.A.1| | 1 |
Offside Headlamp aim not tested |1.8.A.1c| | 1 |
Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside brake drum contaminated by brake fluid |3.5.1h| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
Centre Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Front Parking brake mechanism/associated mounting prescribed area is severely distorted |3.1.9| | 1 |
Nearside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
Offside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
Brake servo vacuum pipe excessively chafed |3.6.C.1b| | 1 |
Offside Wheel nut|s| loose |4.2.A.1e| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Brake hose damaged | 1 |
Rear brake binding | 1 |
Steering retaining device missing |2.2.C.1g| | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |