| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 32 |
| Parking brake: efficiency below requirements |3.7.B.7| | 12 |
| Rear parking brake recording little or no effort | 11 |
| Offside Rear fog lamp not working |1.3.2b| | 8 |
| Headlamp aim out of alignment | 8 |
| Registration plate issues | 8 |
| Rear brake application uneven | 8 |
| Registration plate lamp issues | 6 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 4 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Emissions not tested |7.0| | 4 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
| Brakes imbalanced across an axle | 3 |
| Offside Rear fog lamp missing |1.3.2a| | 3 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 3 |
| Offside Front Statutory seat belt missing |5.1.1| | 3 |
| Horn not working |1.6.2a| | 3 |
| Ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 3 |
| Rear brake binding | 2 |
| Intermediate drop arm insecure |2.2.B.1a| | 2 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Upper Ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Exhaust mounting missing |7.1.1b| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Steering box insecure |2.2.B.1a| | 2 |
| Rear Statutory seat belt missing |5.1.1| | 2 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front passenger seat insecure |6.2.3| | 2 |
| Body has a projection caused by damage |6.1.C.1| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Centre Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Upper Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Rear Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Coil spring mounting cracked |2.4.C.3b| | 1 |
| Nearside Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Track rod end loose |2.2.B.1d| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Brake pipe seriously damaged |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Wheel insecure |4.2.A.1c| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Windscreen has damage | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Nearside rear brakes release unevenly |3.7.B.4| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Offside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Suspension spring mounting prescribed area is fractured |2.4.A.3| | 1 |
| Brake pipe inadequately supported |3.6.B.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Direction indicator insecure |1.4.A.2b| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Outer Front Track rod end loose |2.2.B.1d| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Side repeater not working |1.4.A.2c| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Offside Front Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Rear wheel bearing has excessive play |2.6.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Front Brake back plate|s| locking device missing |3.5.1l| | 1 |
| Rear Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Rear Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Side repeater missing |1.4.A.2b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Front Seat belt damaged (7.1.2 (b) (i)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Seat belt not functioning as intended doesnt lock into buckle (7.1.2 (c)) | 1 |
| Brake pipe leaking on a hydraulic braking system front to rear (1.1.11 (b) (ii)) | 1 |
| All direction indicators not working all 4 (4.4.1 (a) (ii)) | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Rear Parking brake lever is located so that it cannot be satisfactorily operated from the driver`s seat |3.1.3c| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Outer Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting MARKED IN YELLOW (6.2.2 (d) (i)) | 1 |
| Nearside Rear Outer Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting MARKED IN YELLOW (6.2.2 (d) (i)) | 1 |
| Nearside Rear Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting MARKED IN YELLOW (6.2.2 (d) (i)) | 1 |
| Offside Rear Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Nearside Rear Inner Integral body structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired WHEEL ARCH (6.2.2 (d) (ii)) | 1 |
| Offside Rear Inner Integral body structure has excessive corrosion which adversely affects braking or steering (6.1.1 (c) (ii)) | 1 |
| Nearside Front Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting SILL (6.2.2 (d) (i)) | 1 |
| Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting SILL (6.2.2 (d) (i)) | 1 |
| Rear Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition (8.1.1 (a)) | 1 |
| Rear Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Nearside Ball joint ball pin shank loose |2.2.B.1c| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Rear fog lamp not working |1.3.2b| | 1 |
| Bootlid cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Headlamp aim beam image too far to the left |1.6.B4| | 1 |
| Offside Headlamp aim beam image too far to the left |1.6.B4| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Nearside Rear Shock absorber detached |2.7.2b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |