| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Registration plate lamp issues | 4 |
| Hazard warning switch faulty |1.4.B.1d| | 4 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 4 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 4 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.2| | 2 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Headlamp aim out of alignment | 2 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Rear brake application uneven | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Centre Front Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Front suspension has excessive play in a pin or bush of an upper wishbone inner bearing |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a pin or bush of an upper wishbone inner bearing |2.5.B.1a| | 1 |
| Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Centre Front Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Nearside Rear Passenger`s seat security significantly reduced |6.5.14| | 1 |
| Offside Rear Passenger`s seat security significantly reduced |6.5.14| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |6.3.2a| | 1 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Fuel system component insecure |7.2.1| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Brake valve damaged |3.6.A.2c| | 1 |
| Offside Front Lower Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Brake has no servo assistance |3.3.B.2| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Front Steering column universal joint has excessive play |2.1.5| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear brake binding | 1 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front Lower Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Bonnet retaining device excessively deteriorated |8.4.2| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Front brake application uneven | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Rear fog lamp light intensity significantly reduced (4.5.4 (a)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a) (ii)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Brakes imbalanced across an axle | 1 |
| Rear rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded inner wheel arch |2.4.A.3| | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Rear Wheel Arch has a corrosion more then 10mm |6.1.1 |c| |i|| | 1 |
| Exhaust emits excessive smoke or vapour likely to obscure the vision of other road users |8.2.2.2 |c|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Windscreen has damage | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Steering column universal joint is excessively deteriorated |2.1.5| | 1 |
| Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust has a major leak of exhaust gases |6.3.2a| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Emissions not tested |7.0| | 1 |