| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 14 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Registration plate issues | 8 |
| Registration plate lamp issues | 7 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 7 |
| Brake pipe excessively corroded | 6 |
| Horn not working |1.6.2a| | 5 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 5 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Centre Exhaust system not adequately supported |7.1.1| | 4 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Rear fog lamp switch faulty |1.3.1a| | 3 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 3 |
| Rear brake application uneven | 3 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Emissions not tested |7.0| | 2 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Exhaust has a part missing |7.1.1a| | 2 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Rear fog lamp flickers when tapped lightly by hand |1.1.6d| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Exhaust emits visible black smoke at idle |7.3.A.2b| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Nearside Front Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Above shock mounting holed by corrosion (5.3.6 (a) (i)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Nearside Outer Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Outer Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Upper Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Front Lower Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Loading door cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Sub-frame has excessive play in a pin/bush |2.4.G.2| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Centre Front Statutory seat belt missing |5.1.1| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Offside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Front Shock absorber has an excessively worn linkage |2.7.4| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Ball joint has excessive play |2.2.B.1f| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |