| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 32 |
| Brake pipe excessively corroded | 25 |
| Headlamp aim out of alignment | 24 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 7 |
| Nearside Stop lamp not working |1.2.1b| | 6 |
| Rear brake disc in such a condition that it is seriously weakened | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
| Brake hose excessively deteriorated | 5 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Registration plate issues | 4 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Brake performance not tested (1.2.1 (g)) | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Electronic parking brake warning indicates a malfunction (1.1.6 (e)) | 2 |
| Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.5 |b| |i|| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Suspension arm has an unsafe modification wishbone excessive play (5.3.3 (c) (i)) | 1 |
| Nearside Front Suspension arm has an unsafe modification wishbone excessive play (5.3.3 (c) (i)) | 1 |
| Nearside Front Position lamp not working side lamp (4.2.1 (a) (ii)) | 1 |
| Rear Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Brake hose leaking |3.6.A.1| | 1 |
| Brake performance not tested brake fluid leaking |3.7.A.1| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
| Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Road wheel fractured (5.2.2 (a)) | 1 |
| Stop lamp(s) not working Highrise (4.3.1 (a) (ii)) | 1 |
| Nearside Front Road wheel fractured 2x Cracks (5.2.2 (a)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Road wheel fractured (5.2.2 (a)) | 1 |
| Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Rear Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Position lamp not working all position lamps (4.2.1 (a) (ii)) | 1 |
| Horn not working |1.6.2a| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp position lamp |1.4.A.2h| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Front Position lamp not working both |4.2.1 |a| |ii|| | 1 |
| Nearside Front Bumper damaged and likely to cause injury when grazed or contacted |6.1.4 |a| |i|| | 1 |
| Fuel system component leaking |6.1.3 |b| |i|| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Rear Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Offside Rear Brake pipe leaking on an air braking system (1.1.11 (b) (i)) | 1 |
| Nearside Floor excessively deteriorated step area (6.2.4 (a) (i)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Front Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Suspension component modified so the suspension is inoperative (5.3.3 (c) (ii)) | 1 |
| Offside Rear Upper Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Brake performance not tested park brake issue, brakes not tested (1.2.1 (g)) | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Fuel tank exhaust shield missing where fitted as original equipment creating a risk of fire (6.1.3 (e)) | 1 |
| Suspension component mounting prescribed area excessively corroded significantly reducing structural strength fuel tank guard (5.3.6 (a) (i)) | 1 |
| Electronic parking brake control defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
| Prop shaft bearing likely to break up (6.1.7 (b) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front position lamp|s| not working side light |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working side light |1.1.A.3b| | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system Heavily corroded (1.1.11 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Rear Upper Suspension arm corroded and seriously weakened has a hole in it (5.3.3 (b) (i)) | 1 |
| Nearside Front Inner Braking system leaking caliper bleed nipple |3.6.A.1| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Hydraulic brake calliper leaking bleed screw |1.1.16 |b| |i|| | 1 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Front Brake disc significantly and obviously worn both (1.1.14 (a) (i)) | 1 |
| Rear Inner Brake disc significantly and obviously worn both (1.1.14 (a) (i)) | 1 |
| Front Inner Suspension arm pin or bush excessively worn both front inner wishbone bushes (5.3.4 (a) (i)) | 1 |
| Nearside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Sill (6.1.1 (c) (i)) | 1 |
| Offside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Sill (6.1.1 (c) (i)) | 1 |
| Air/vacuum reservoir inadequately mounted (1.1.9 (c)) | 1 |
| Rear Exhaust emits clearly visible black smoke during acceleration (8.2.1.2 (g)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting centre inner sill (6.2.2 (d) (i)) | 1 |
| Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting centre inner sill (6.2.2 (d) (i)) | 1 |
| Nearside Front Integral body structure inadequately repaired such that structural rigidity is significantly reduced inner sill (6.1.1 (d) (i)) | 1 |
| Offside Front Integral body structure inadequately repaired such that structural rigidity is significantly reduced inner sill (6.1.1 (d) (i)) | 1 |
| Offside Rear Integral body structure inadequately repaired such that structural rigidity is significantly reduced inner sill (6.1.1 (d) (i)) | 1 |
| Rear Suspension component modified so the suspension is inoperative n/s & o/s (5.3.3 (c) (ii)) | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis (6.1.1 (c) (i)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Hydraulic brake cylinder leaking hydraulic fluid Calliper (1.1.16 (b) (i)) | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Bonnet primary retaining device ineffective (3.1 (c)) | 1 |
| Nearside Front Cab steps so insecure it is likely to cause injury (6.2.8 (a) (ii)) | 1 |
| Offside Front Cab steps so insecure it is likely to cause injury (6.2.8 (a) (ii)) | 1 |
| Nearside Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn front bush (5.3.4 (a) (i)) | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Headlamp cleaning device inoperative |1.7.2| | 1 |
| Nearside Side repeater incorrect colour |4.4.3 |a|| | 1 |
| Offside Side repeater incorrect colour |4.4.3 |a|| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush |5.3.4 |a| |i|| | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush rear bush |2.4.G.2| | 1 |
| Prop shaft likely to become detached (6.1.7 (a) (ii)) | 1 |
| Central Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Windscreen washer not working | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Fuel system component leaking fuel tank area (6.1.3 (b) (i)) | 1 |
| Nearside Outer Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Electrical wiring inadequately supported |1.9.2a| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint linke |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement back bush |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm synthetic bush deteriorated resulting in excessive movement back bush |2.4.G.2| | 1 |