Most common failures | No# failures |
---|
Headlamp aim out of alignment | 13 |
Parking brake: efficiency below requirements |3.7.C.1b| | 7 |
Brakes imbalanced across an axle | 7 |
Registration plate lamp issues | 6 |
Brake hose excessively deteriorated | 5 |
Brake pipe excessively corroded | 5 |
Windscreen wiper does not clear the windscreen effectively | 5 |
Offside Stop lamp not working |1.2.1b| | 4 |
Parking brake: efficiency below requirements |3.7.B.7| | 4 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Rear brake binding | 4 |
Steering wheel retaining device insecure |2.1.6| | 3 |
Parking brake lever has no reserve travel |3.1.6b| | 3 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 2 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 2 |
Steering box insecure |2.2.B.1a| | 2 |
Horn not working |1.6.2a| | 2 |
Brake pipe inadequately clipped |3.6.B.1| | 2 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Registration plate issues | 2 |
Rear Mechanical brake component has restricted free movement | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Battery insecure |1.9.1| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Service brake: efficiency below requirements |3.7.B.7| | 2 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Service brake: efficiency below requirements |3.7.C.1a| | 2 |
Offside Headlamp not in good working order |not working| |1.2.4a| | 2 |
Windscreen washer not working | 1 |
Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
Offside Rear Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
Nearside Front Drag link end modification unsafe fouling body part |2.1.3 |f| |i|| | 1 |
Seat belt missing x3 |7.1.2 |a|| | 1 |
Offside Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Offside Rear Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Fuel hose leaking |7.2.3| | 1 |
Wheel insecure |4.2.A.1c| | 1 |
Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Offside Front Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings centre |6.1.B.2| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Nearside Statutory seat belt missing |5.1.1| | 1 |
Offside Statutory seat belt missing |5.1.1| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Front Axle king pin so loose it is likely to affect directional stability (5.1.2 (d) (ii)) | 1 |
Service brake is causing the steering wheel to severely pull one way (1.2.1 (b) (i)) | 1 |
Offside Front Upper Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Headlamp switch faulty |1.7.1| | 1 |
An item not tested |Manual| | 1 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Centre Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Nearside Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Exhaust emits excessive dense blue smoke during acceleration |7.4.A2| | 1 |
Nearside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Centre Brake clevis joint locking device insecure |3.5.1l| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Headlamp not working on dipped beam being affected by main beam |earth fault| |4.1.1 |a| |ii|| | 1 |
Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
Rear brake excessively fluctuating | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Exhaust emits clearly visible black smoke during acceleration |7.4.A2| | 1 |
Offside Front front brake recording little or no effort |3.7.B.5a| | 1 |
Horn not working Not working at all, temp repair applied at time of test and just about working well enough, but needs a proper repair ASAP |7.7 |a| |ii|| | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Front front brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Nearside Inner Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Brake pipe leaking |3.6.A.1| | 1 |
Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Ball joint has excessive play |2.2.B.1f| | 1 |
Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Nearside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Intermediate drop arm insecure |2.2.B.1a| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
Rear brake application uneven | 1 |
Offside Front Stop lamp not working |1.2.1b| | 1 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Front brake drum contaminated by oil |3.5.1h| | 1 |
Nearside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Offside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front brake application uneven | 1 |
Nearside front brake grabbing severely |3.7.A.2b| | 1 |
Offside front brake grabbing severely |3.7.A.2b| | 1 |
Nearside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
Exhaust emits dense blue smoke at idle |7.4.A.1| | 1 |