| Most common failures | No# failures |
|---|
| Registration plate issues | 97 |
| Headlamp aim out of alignment | 97 |
| Windscreen wiper does not clear the windscreen effectively | 72 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 62 |
| Brake pipe excessively corroded | 35 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 22 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 19 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 9 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 9 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 8 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 8 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 7 |
| Front brake disc in such a condition that it is seriously weakened | 6 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 6 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 6 |
| Brake hose excessively deteriorated | 6 |
| Brake performance not tested (1.2.1 (g)) | 5 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 5 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Electronic parking brake warning indicates a malfunction (1.1.6 (e)) | 4 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 4 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 4 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 4 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Nearside Front Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 3 |
| Offside Front Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 3 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 3 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 3 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 3 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 3 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Windscreen washer not working | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Registration plate lamp issues | 2 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Offside Front Lower Suspension arm pin or bush excessively worn front arm (5.3.4 (a) (i)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 2 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Rear Rear fog lamp lens defective such that emitted light is adversely affected (4.5.1 (b) (ii)) | 2 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Front Headlamp insecure (4.1.1 (c)) | 2 |
| Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt rear (5.3.4 (b) (ii)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 2 |
| Brake performance unable to be tested (1.2.1 (g)) | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt rear arm (5.3.4 (b) (ii)) | 2 |