| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 26 |
| Registration plate lamp issues | 22 |
| Headlamp aim out of alignment | 19 |
| Registration plate issues | 19 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 17 |
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 12 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 9 |
| Brake hose excessively deteriorated | 9 |
| Rear parking brake recording little or no effort | 7 |
| Nearside Stop lamp not working |1.2.1b| | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 7 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 6 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Electronic parking brake warning indicates a malfunction |3.1.7| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 4 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 4 |
| Headlamps matched pair are not the same colour |1.7.6| | 3 |
| Offside Front Direction indicator not working |1.4.A.2c| | 3 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Fuel pipe leaking |7.2.3| | 2 |
| Nearside Rear Road wheel cracked |4.2.A.1a| | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 2 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Electronic parking brake warning indicates a malfunction |1.1.6 |e|| | 2 |
| Windscreen washer not working | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 2 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Emissions not tested (8.2.1.2 (d)) | 2 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Nearside Front Wheel bearing play so excessive it is likely to break up |5.1.3 |a| |ii|| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush rear bush |2.4.G.2| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Offside Inner Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Upper Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Front Front suspension has excessive play in a pin or bush of a lower wishbone inner bearing both |2.5.B.1a| | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Rear Inner Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Rear Inner Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Nearside Rear Exhaust emissions likely to be affected by an exhaust leak tail; missing |8.2.2.1 |b|| | 1 |
| Offside Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Brake lining|s| wear indicator illuminated |1.1.13 |a| |i|| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Upper Stop lamp not working |1.2.1b| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Nearside Rear Suspension arm locating pin insecure |2.4.G.3a| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.5 |b| |i|| | 1 |
| Offside Front Bumper damaged and likely to cause injury when grazed or contacted bumper |6.1.4 |a| |i|| | 1 |
| Nearside Front Body component damaged and likely to cause injury headlight glass broken |6.2.1 |a| |i|| | 1 |
| Nearside Front Body component damaged and likely to cause injury wing damaged |6.2.1 |a| |i|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Electronic parking brake control defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Nearside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Inner Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamp cleaning device obviously defective |1.7.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush inner rear bush as marked |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front brake disc excessively scored |3.5.1h| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Brake pipe connection leaking on a hydraulic braking system flexi hose |1.1.11 |b| |ii|| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Rear brake binding | 1 |
| Fuel hose leaking |6.1.3 |b| |i|| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement D bushes |2.4.G.2| | 1 |
| Tie bar/rod has excessive play in a ball joint both rear |2.4.G.2| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Nearside Front Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Parking brake inoperative on one side both rears fully on (1.4.1 (a)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Electronic parking brake control inoperative (1.1.6 (d)) | 1 |
| Brake performance not tested electric handbrake inop (1.2.1 (g)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Hydraulic fluid leaking excessively brake pipe to brake hose (8.4.1 (a) (i)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Inner Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn centre rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn centre rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Rear Brake pipe leaking on an air braking system (1.1.11 (b) (i)) | 1 |
| Offside Rear Brake pipe leaking on an air braking system (1.1.11 (b) (i)) | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Steering wheel has movement relative to the column indicating looseness (2.2.1 (a) (i)) | 1 |
| Fuel pipe leaking (6.1.3 (b) (i)) | 1 |
| Central Prop shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Nearside Rear fog lamp lens defective such that emitted light is adversely affected (4.5.1 (b) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Electronic braking system warning device indicates a fault (1.7 (b)) | 1 |
| Electrical wiring insecure and in contact with sharp edges X2 (4.11 (a) (ii)) | 1 |
| Nearside Front Wheel bearing play so excessive that directional control is impaired (5.1.3 (a) (ii)) | 1 |
| Nearside Rear Wheel bearing play so excessive that directional control is impaired (5.1.3 (a) (ii)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Central Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard both (8.2.1.1 (a)) | 1 |
| Emissions oxygen sensor missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Electronic parking brake control inoperative switch inop (1.1.6 (d)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Nearside Front Position lamp lens seriously defective (4.2.1 (b)) | 1 |
| Offside Front Position lamp lens seriously defective (4.2.1 (b)) | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid (1.1.16 (b) (i)) | 1 |
| Offside Rear Fluid leak harmful to the environment or a risk to other road users diesel leak (8.4.1 (a) (i)) | 1 |
| Nearside Rear Suspension arm ball joint excessively worn track rod arm (5.3.4 (a) (i)) | 1 |
| Prop shaft joint so worn it is likely to fail (6.1.7 (c) (ii)) | 1 |
| Prop shaft bearing housing likely to fail (6.1.7 (f) (ii)) | 1 |
| Prop shaft bearing likely to break up (6.1.7 (b) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Body component damaged and likely to cause injury bumper (6.2.1 (a) (i)) | 1 |
| Offside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Front Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 1 |
| Nearside Rear Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values alot of smoke (8.2.2.2 (f)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Front Position lamp not working Both side (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Other passenger door likely to open inadvertently or not remain closed (6.2.3 (b) (ii)) | 1 |
| Position lamp not working both front (4.2.1 (a) (ii)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |