| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Brake pipe excessively corroded | 5 |
| Registration plate lamp issues | 4 |
| Headlamp aim out of alignment | 3 |
| Offside Rear Shock absorbers has a serious fluid leak | 2 |
| Brake hose excessively deteriorated | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Horn not working |1.6.2a| | 2 |
| Power steering component|s| leaking |2.3.3b| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Rear Body insecure and dangerous to other road users cross member |6.1.B.1b| | 2 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Drag link end ball joint has excessive play DROP ARM BALLJOINT (2.1.3 (b) (i)) | 1 |
| Power steering pump leaking (2.1.5 (a)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Electrical wiring likely to touch hot or rotating parts 2 LOOSE CABLES/WIRING UNDERSIDE DANGLING DOWN (4.11 (a) (iii)) | 1 |
| Bonnet primary retaining device insecure BONNET SUPPORT PROP LOOSE UNDER BONNET AND UNABLE TO SECURE IN UPRIGHT POSITION (3.1 (c)) | 1 |
| Seat belt missing CENTRE BELT MISSING(SEAT FITTED) (7.1.2 (a)) | 1 |
| Fuel tank leaking (6.1.3 (b) (i)) | 1 |
| Oil leaking excessively from transmission Gearbox. (8.4.1 (a) (i)) | 1 |
| Windscreen in an unacceptable condition MISSING (3.2 (c) (i)) | 1 |
| Front Windscreen wiper missing (3.4 (a)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Front Seat belt anchorage loose ALL FRONT SEAT BELTS INSECURE (7.1.1 (b)) | 1 |
| Fuel system component leaking PUMP AREA (6.1.3 (b) (i)) | 1 |
| Lower Steering column top bearing excessively worn U/J LOOSE (2.2.2 (b)) | 1 |
| Steering column top bearing excessively worn LOWER COLUMN LOOSE (2.2.2 (b)) | 1 |
| Steering box has excessive free play detected at the steering wheel to the extent that safe steering is affected (steering box fitted) DROP ARM BALL JOINT VERY LOOSE (2.3 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced CROSS MEMBER (6.1.1 (c) (i)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Drivers door does not latch securely closed MISSING? (6.2.3 (a)) | 1 |
| Front passenger door does not latch securely closed MISSING? (6.2.3 (a)) | 1 |
| Front Passengers seat insecure CENTRE BASE (6.2.6 (a) (ii)) | 1 |
| Nearside Windscreen wiper missing (3.4 (a)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt Steering drop arm ball joint (2.1.3 (g) (ii)) | 1 |
| Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Nearside front floor panel (6.2.2 (d) (i)) | 1 |
| Nearside Rear Direction indicator likely to become detached (4.4.1 (c) (ii)) | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Registration plate issues | 1 |
| Nearside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Towbar excessively corroded within 30cm of towbar mounting chassis (6.1.6 (i) (i)) | 1 |
| Offside Front Brake actuating linkage mounting prescribed area is excessively corroded floor pan (1.1.21 (e) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Nearside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Front Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting floor (6.2.2 (d) (i)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Offside Rear Body insecure and dangerous to other road users cross member |6.1.B.1b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear Upper Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Drivers seat backrest cannot be secured in the upright position. (6.2.5 (b) (ii)) | 1 |
| Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Offside Front brake disc contaminated by oil |3.5.1h| | 1 |