| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 10 |
| Brakes imbalanced across an axle | 7 |
| Registration plate lamp issues | 6 |
| Brake pipe excessively corroded | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Rear brake drum contaminated by oil |3.5.1h| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Front brake application uneven | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Brake hose excessively deteriorated | 2 |
| Headlamp not working on dipped beam both (4.1.1 (a) (ii)) | 2 |
| Offside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Registration plate issues | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Headlamp aim projected beam image is obviously incorrect both lamps Left hand dip |masks fitted at time of test| |4.1.2 |c|| | 1 |
| Horn not working |1.6.2a| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Front Headlamp reflector seriously defective |4.1.1 |b| |ii|| | 1 |
| Offside Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Brake lever has insufficient reserve travel park |1.1.2 |a|| | 1 |
| Offside Front Steering box insecure bolts loose |2.1.3 |a| |i|| | 1 |
| Nearside Rear Rear reflector missing |4.8.2 |a| |ii|| | 1 |
| Offside Rear Rear reflector missing |4.8.2 |a| |ii|| | 1 |
| Offside Front Drag link end loose |2.2.B.1d| | 1 |
| Offside Steering box insecure |2.2.B.1a| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |1.1.16 |b| |i|| | 1 |
| Offside Front Hydraulic brake cylinder leaking hydraulic fluid Brake pipe to wheel cylinder |1.1.16 |b| |i|| | 1 |
| Nearside Front Suspension spring mounting prescribed area excessively damaged significantly reducing structural strength Spring mounting |5.3.6 |a| |i|| | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Central Front Steering component mounting prescribed area is excessively corroded |2.1.2 |e| |i|| | 1 |
| Exhaust system insecure |6.1.2 |a|| | 1 |
| Nearside Rear Brake drum contaminated |1.1.14 |b|| | 1 |
| Front Service brake lagging in operation |1.2.1 |d|| | 1 |
| Rear Service brake lagging in operation |1.2.1 |d|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Service brake is causing the vehicle to swerve to the offside (1.2.1 (b) (i)) | 1 |
| Front Steering component mounting prescribed area is excessively corroded transverse chassis (2.1.2 (e) (i)) | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Offside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Position lamp not working all (4.2.1 (a) (ii)) | 1 |
| Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Headlamp not working on main beam both (4.1.1 (a) (ii)) | 1 |
| Central Seat belt missing front (7.1.2 (a)) | 1 |