Most common failures | No# failures |
---|
Headlamp aim out of alignment | 20 |
Registration plate lamp issues | 20 |
Brake pipe excessively corroded | 15 |
Offside Stop lamp not working |1.2.1b| | 8 |
Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 7 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 6 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 6 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 5 |
Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 5 |
Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
Brake hose excessively deteriorated | 4 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
Windscreen wiper does not clear the windscreen effectively | 4 |
Registration plate issues | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Emissions not tested (8.2.1.2 (d)) | 2 |
Offside Rear Exhaust system not adequately supported |7.1.1| | 2 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Electronic parking brake warning indicates a malfunction |3.1.7| | 2 |
Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
Offside Front brake caliper locking device insecure |3.5.1l| | 2 |
Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
Suspension system inoperative |5.3.5 |a|| | 2 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Inner Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Inner Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Central Exhaust system not adequately supported |7.1.1| | 1 |
Rear Brake pipe leaking |3.6.A.1| | 1 |
Windscreen has damage | 1 |
Offside Front Brake hose leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Upper Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Horn not working |1.6.2a| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Lower Suspension arm has excessive play in a ball joint Hub bush |2.4.G.2| | 1 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush front bush |2.4.G.2| | 1 |
Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
Nearside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Inner sill is seriously corroded. |6.2.2 |d| |i|| | 1 |
Offside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Inner sill is seriously corroded. |6.2.2 |d| |i|| | 1 |
Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner arch which forms part of vehicle body is seriously corroded. |5.3.6 |a| |i|| | 1 |
Offside Front Track rod end ball joint has excessive play and rubber split (2.1.3 (b) (i)) | 1 |
Steering column has excessive movement up and down side to side movement (2.2.2 (a)) | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
Offside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Upper Suspension arm pin or bush excessively worn front and rear bushes (5.3.4 (a) (i)) | 1 |
Front Service brake excessively binding o/s (1.2.1 (f)) | 1 |
Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 1 |
Offside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
Offside Rear Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Rear Anti-roll bar pin or bush excessively worn D bush (5.3.4 (a) (i)) | 1 |
Offside Rear Anti-roll bar pin or bush excessively worn D bush (5.3.4 (a) (i)) | 1 |
Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Rear Upper Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Offside Rear Lower Suspension rod pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Offside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
Offside Inner Ball joint has excessive play tie rod |2.2.B.1f| | 1 |
Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
Headlamp cleaning device inoperative |1.7.2| | 1 |
Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 1 |
Nearside Electronic parking brake control inoperative |1.1.6 |d|| | 1 |
Offside Electronic parking brake control inoperative |1.1.6 |d|| | 1 |
Nearside Cab steps in such a condition that it is likely to cause injury |6.2.8 |b|| | 1 |
Offside Cab steps in such a condition that it is likely to cause injury |6.2.8 |b|| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Nearside Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear fog lamp not working |1.3.2b| | 1 |
Lower Steering column universal joint has excessive play |2.1.5| | 1 |
Offside Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement inner bush |2.4.G.2| | 1 |
Offside Front brake caliper securing device loose bolt insecure |3.5.1j| | 1 |
Offside Rear Upper Suspension arm has excessive play in a pin/bush rear bush |2.4.G.2| | 1 |
Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
Prop shaft bearing excessively worn |6.1.7 |b| |i|| | 1 |
Nearside Rear Road wheel fractured |5.2.2 |a|| | 1 |
Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
Offside Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement inner |2.4.G.2| | 1 |
Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Front Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Rear Upper Suspension arm pin or bush excessively worn inner bush (5.3.4 (a) (i)) | 1 |
Nearside Front Lower Suspension arm pin or bush excessively worn Lower arm rear bush worn (5.3.4 (a) (i)) | 1 |
Offside Front Lower Suspension arm pin or bush excessively worn Lower arm rear bush worn (5.3.4 (a) (i)) | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
Nearside Front Upper Suspension arm pin or bush excessively worn Inner bush (5.3.4 (a) (i)) | 1 |
Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Offside Front Direction indicators not working |1.4.A.2c| | 1 |
Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt insecure (2.1.3 (g) (ii)) | 1 |
Offside Front Inner Track rod end ball joint has excessive play steering arm (2.1.3 (b) (i)) | 1 |
Engine MIL inoperative or indicates a malfunction Light on (8.2.1.2 (h)) | 1 |
Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
Offside Rear Towbar excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 1 |
Windscreen washer not working | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Rear Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shock (5.3.6 (a) (i)) | 1 |
Offside Rear Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shock (5.3.6 (a) (i)) | 1 |
Nearside Headlamp insecure |4.1.1 |c|| | 1 |
Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
Rear Suspension rod pin or bush excessively worn Center stabiliser bush in the middle as marked with yellow chalk |5.3.4 |a| |i|| | 1 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering Where repaired previously |6.1.1 |c| |ii|| | 1 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
Centre Stop lamp not working |1.2.1b| | 1 |
Power steering component leaking (2.1.5 (a)) | 1 |
Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
Offside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
Oil leaking excessively from transmission (8.4.1 (a) (i)) | 1 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced - Sill (6.1.1 (c) (i)) | 1 |
Offside Rear Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill |7.1.1 |a| |i|| | 1 |
Offside Rear Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill |7.1.1 |a| |i|| | 1 |
Seat belt damaged sufficient to significantly weakened the webbing both rear in boot |5.2.2a| | 1 |
Lower Steering column universal joint has excessive wear or play (2.2.2 (c)) | 1 |
Offside Rear Suspension rod pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Nearside Rear Suspension rod pin or bush excessively worn tie rod bar |5.3.4 |a| |i|| | 1 |
Offside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
Offside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Inner Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
Offside Inner Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced outer sills, (7.1.1 (a) (i)) | 1 |
Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Nearside Inner Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Inner Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Fuel system component defective in the case of LPG/CNG/ LNG or hydrogen systems fuel tank corroded to excess |6.1.3 |f|| | 1 |
Suspension component insecurely attached switch |5.3.3 |a| |i|| | 1 |
Nearside Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |