| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Headlamp aim out of alignment | 13 |
| Brake pipe excessively corroded | 9 |
| Registration plate lamp issues | 6 |
| Windscreen washer not working | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Registration plate issues | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Brake hose excessively deteriorated | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 3 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 2 |
| Windscreen has damage | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| brake drum contaminated by oil |3.5.1h| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn rear wishbone bush (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn rear wishbone bush (5.3.4 (a) (i)) | 1 |
| Stop lamp not working both side |1.2.1b| | 1 |
| Offside Headlamp aim does not move downwards when dipped |British American headlamp| |1.8.C.4| | 1 |
| Nearside Headlamp aim does not move downwards when dipped |British American headlamp| |1.8.C.4| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Anti-roll bar pin or bush excessively worn both rear d bushes |5.3.4 |a| |i|| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn inner pivot bush (5.3.4 (a) (i)) | 1 |
| Nearside Brake cable guide defective and affecting operation (1.1.15 (d)) | 1 |
| Offside Brake cable guide defective and affecting operation (1.1.15 (d)) | 1 |
| Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Horn not working (7.7 (a)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Rear Seat belt buckle damaged covers missing |7.1.2 |d|| | 1 |
| Nearside Front Windscreen wiper not working wiper arm insecure |3.4 |a|| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Electronic parking brake control defective so that it cannot be satisfactorily operated Wouldnt release (1.1.6 (d)) | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension rod pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Electrical wiring connectors for braking disconnected |4.11 |a| |iii|| | 1 |
| Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush REAR LOWER BUSH |2.4.G.2| | 1 |
| Engine MIL inoperative or indicates a malfunction on dash |8.2.1.2 |h|| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush both front D bushes worn |2.4.G.2| | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn inner bush (5.3.4 (a) (i)) | 1 |
| Offside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Offside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Offside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working bumper (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Upper Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Upper Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Rear Inner Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Brake performance unable to be tested Leaking brake pipe. (1.2.1 (g)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced sill holed at door pillar (7.1.1 (a) (i)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced sill holed at door pillar (7.1.1 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch holed (5.3.6 (a) (i)) | 1 |
| Emissions unable to be completed due to exhaust blow (8.2.1.2 (d)) | 1 |
| Nearside Rear Braking system leaking brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn outer bush on stabiliser arm (5.3.4 (a) (i)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill next to mounting (6.1.1 (c) (i)) | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Suspension arm has excessive play in a pin/bush NSR TOP INNER BUSH |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn outer (5.3.4 (a) (i)) | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn forward bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn forward bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Inner Suspension arm ball joint excessively worn toe control arm (5.3.4 (a) (i)) | 1 |
| Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Central Rear Seat belt missing (7.1.2 (a)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Central Rear Seat belt retracting mechanism defective |7.1.2 |e|| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear brake binding | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Central Rear Suspension component ball joint dust cover no longer prevents the ingress of dirt diff support (5.3.4 (b) (ii)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill at (7.1.1 (a) (i)) | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Windscreen wiper blade insecure | 1 |
| Stop lamp not working rear offside |1.2.1b| | 1 |
| Front position lamp|s| not working front nearside |1.1.A.3b| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front Body component insecure plastic trim on door (6.2.1 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Seat belt stitching badly frayed |5.2.2b| | 1 |
| Nearside Inner Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Inner Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Trailing arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement inner arm bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar synthetic mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar synthetic mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |