Most common failures | No# failures |
---|
Headlamp aim out of alignment | 120 |
Windscreen wiper does not clear the windscreen effectively | 93 |
Brakes imbalanced across an axle | 90 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 77 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 69 |
Brake pipe excessively corroded | 56 |
Registration plate lamp issues | 56 |
Offside Stop lamp not working |1.2.1b| | 52 |
Nearside Stop lamp not working |1.2.1b| | 51 |
Horn not working |1.6.2a| | 50 |
Offside Front position lamp|s| not working |1.1.A.3b| | 45 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 39 |
Parking brake: efficiency below requirements |3.7.C.1b| | 39 |
Service brake: efficiency below requirements |3.7.C.1a| | 38 |
Parking brake: efficiency below requirements |3.7.B.7| | 32 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 30 |
Front brake application uneven | 30 |
Rear brake binding | 29 |
Registration plate issues | 28 |
Service brake: efficiency below requirements |3.7.B.7| | 25 |
Offside Headlamp not working on dipped beam |1.7.5a| | 24 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 23 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 23 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 22 |
Offside Headlamp not working on main beam |1.7.5a| | 22 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 21 |
Brake hose excessively deteriorated | 21 |
Exhaust has a major leak of exhaust gases |7.1.2| | 21 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 20 |
Nearside Front Direction indicator not working |1.4.A.2c| | 20 |
Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 20 |
Parking brake lever has no reserve travel |3.1.6b| | 20 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 19 |
Offside Rear Stop lamp not working |1.2.1b| | 19 |
Nearside Rear Stop lamp not working |1.2.1b| | 18 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 18 |
Battery insecure |1.9.1| | 18 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 17 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 16 |
Offside Front Direction indicator not working |1.4.A.2c| | 16 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 16 |
Stop lamp not working |1.2.1b| | 16 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 15 |
Nearside Headlamp not working on main beam |1.7.5a| | 15 |
Brake pedal spongy |3.3.B.1b| | 15 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 14 |
Exhaust system not adequately supported |7.1.1| | 14 |
Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 13 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 13 |
Nearside front brake binding |3.7.B.1| | 13 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 12 |
Offside Rear Direction indicator not working |1.4.A.2c| | 12 |
Rear brake application uneven | 12 |
Rear Exhaust system not adequately supported |7.1.1| | 12 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 11 |
Hazard warning switch faulty |1.4.B.1d| | 11 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 11 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 11 |
Nearside Front front brake binding |3.7.B.1| | 11 |
Windscreen washer not working | 10 |
Rear Stop lamp not working |1.2.1b| | 10 |
Brake performance not tested |3.7.A.1| | 10 |
Offside Front front brake binding |3.7.B.1| | 10 |
Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 10 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 10 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 10 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 10 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 9 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 9 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 9 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 9 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 9 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 9 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 9 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 9 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 9 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 8 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 8 |
Mechanical brake component has restricted free movement | 8 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 8 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 8 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 8 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 8 |
Nearside Rear reflector missing |1.5.1a| | 8 |
Offside Rear reflector missing |1.5.1a| | 8 |
Nearside front brake recording little or no effort |3.7.B.5a| | 8 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 7 |
Centre Exhaust system not adequately supported |7.1.1| | 7 |
Steering box insecure |2.2.B.1a| | 7 |
Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 7 |
Offside Headlamp insecure |1.7.3| | 7 |
Offside Rear Leaf spring fractured |2.4.B.1a| | 7 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 7 |
Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 7 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 7 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 7 |
Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 7 |
Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 7 |
Offside Front Steering pivot point has excessive play |2.2.B.1g| | 7 |
Direction indicators not working |1.4.A.2c| | 7 |
Offside front brake binding |3.7.B.1| | 7 |
Rear parking brake recording little or no effort | 7 |
Fuel system component leaking |7.2.3| | 7 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 7 |
Nearside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 6 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 6 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 6 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 6 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 6 |
Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 6 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 6 |
Fuel tank leaking |7.2.3| | 6 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 6 |
Intermediate drop arm insecure |2.2.B.1a| | 6 |
Offside Rear brake drum contaminated by oil |3.5.1h| | 6 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 6 |
Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 6 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 6 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 6 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 6 |
Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 6 |
Nearside Front Axle swivel joint has excessive play |2.5.A.3b| | 6 |
Headlamp not working on main beam |1.7.5a| | 6 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 6 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 5 |
Centre Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 5 |
Stop lamp remains on when the brakes are released | 5 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 5 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 5 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 5 |
Steering pivot point has excessive play |2.2.B.1g| | 5 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 5 |
Brake pipe inadequately clipped |3.6.B.1| | 5 |
Indicator tell tale inoperative |1.4.A.2a| | 5 |
Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 5 |
Nearside Rear Braking system leaking |3.6.A.1| | 5 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 5 |
Offside Front Brake pipe inadequately supported |3.6.B.1| | 5 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 5 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 5 |
Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 5 |
Offside rear brake recording little or no effort |3.7.B.5a| | 4 |
Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 4 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 4 |
Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 4 |
Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 4 |
Hazard warning lamps inoperative |1.4.B.1b| | 4 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 4 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 4 |
Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 4 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 4 |
Offside Rear wheel cylinder leaking |3.6.A.1| | 4 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 4 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 4 |
Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 4 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 4 |
Offside Front Braking system leaking |3.6.A.1| | 4 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 4 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Rear Mechanical brake component has restricted free movement | 4 |
Steering system excessively tight |2.2.D.1| | 4 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 4 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 4 |
Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 4 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 4 |
Offside front brake recording little or no effort |3.7.B.5a| | 4 |
Driver`s seat insecure |6.2.A.1| | 4 |
Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 4 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 4 |
Brake master cylinder fluid level below minimum level |3.6.G.1e| | 4 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 4 |
Headlamp switch faulty |1.7.1| | 4 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 3 |
Offside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 3 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 3 |
Offside Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 3 |
Offside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Outer Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Rear Brake hose excessively damaged |3.6.B.4d| | 3 |
Speedometer cannot be illuminated. |6.7.3| | 3 |
Offside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
Offside Rear front brake binding |3.7.B.1| | 3 |
Nearside Headlamp insecure |1.7.3| | 3 |
Offside Front Direction indicators not working |1.4.A.2c| | 3 |
Nearside Rear Leaf spring splayed and action impaired |2.4.B.1c| | 3 |
Offside Outer Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Offside Rear Rear reflector missing |1.5.1a| | 3 |
Nearside Front Statutory seat belt missing |5.1.1| | 3 |
Offside Front Statutory seat belt missing |5.1.1| | 3 |
Offside Rear Braking system leaking |3.6.A.1| | 3 |
Nearside Rear Rear reflector missing |1.5.1a| | 3 |
Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 3 |
Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 3 |
Nearside Rear brake drum contaminated by oil |3.5.1h| | 3 |
Offside Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 3 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 3 |
Offside Front Leaf spring fractured |2.4.B.1a| | 3 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 3 |
Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Front brake excessively fluctuating | 3 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 3 |
Nearside Rear Shock absorber detached |2.7.2b| | 3 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
front brake binding |3.7.B.1| | 3 |
Nearside Front Windscreen wiper blade missing |8.2.2| | 3 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 3 |
Nearside Front Leaf spring splayed and action impaired |2.4.B.1c| | 3 |
Headlamp aim not tested |1.8.A.1c| | 3 |
Nearside Rear wheel cylinder leaking |3.6.A.1| | 3 |
Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 3 |
Front passenger seat cannot be secured in the upright position. |6.2.4| | 3 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded front mount |2.4.A.3| | 3 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 3 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
Rear Brake pipe inadequately clipped |3.6.B.1| | 3 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
Front Brake pipe inadequately clipped |3.6.B.1| | 3 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 3 |
Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 3 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 3 |
Offside Rear wheel bearing has excessive play |2.6.2| | 3 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
Indicator switch faulty |1.4.A.1| | 3 |
Brake pipe inadequately supported |3.6.B.1| | 3 |
Offside Direction indicators not working |1.4.A.2c| | 3 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 3 |
Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside Rear Leaf spring shackle bracket corroded and seriously weakened |2.4.B.6d| | 3 |
Offside Rear Shock absorber detached |2.7.2b| | 3 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 3 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 3 |
Nearside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 3 |