| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 7 |
| Headlamp aim out of alignment | 7 |
| Brakes imbalanced across an axle | 5 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
| Brake pipe excessively corroded | 4 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Horn not working |1.6.2a| | 2 |
| All direction indicators not working (4.4.1 (a) (ii)) | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Rear Brake pipe inadequately clipped |3.6.B.1| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Front brake application uneven | 2 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Rear Rear reflector missing |1.5.1a| | 1 |
| Offside Rear Rear reflector missing |1.5.1a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is fractured |2.4.A.3| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Shock absorbers likely to become detached (5.3.2 (a) (ii)) | 1 |
| Nearside Front position lamp(s) not working (1.1.A.3b) | 1 |
| Parking brake lever releases when knocked (3.1.6a) | 1 |
| Offside Rear Leaf spring cracked (2.4.B.1a) | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Offside Front Service brake grabbing severely |3.7.C.2| | 1 |
| Offside Rear Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Oil leaking continuously from engine posing a serious risk to road safety |8.4.1 |a| |ii|| | 1 |
| Offside Rear Vehicle structure is deformed and structural rigidity is significantly reduced previous welding not complete |6.1.1 |a| |i|| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Headlamp not working on dipped beam Both headlamps inoperative on dip or main beam |1.7.5a| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Stop lamp not working both |1.2.1b| | 1 |
| Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Shock absorber detached |2.7.2b| | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Shock absorber casing damaged externally so the unit does not function |2.7.2a| | 1 |
| Offside Front Shock absorber casing damaged externally so the unit does not function |2.7.2a| | 1 |
| Offside Front Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Nearside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Rear brake binding | 1 |
| Offside Front Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Nearside Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Nearside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Registration plate issues | 1 |
| Offside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Fuel system component insecure |7.2.1| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Front Valve stem seriously misaligned |4.1.D.1e| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Brake hose damaged | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Electrical wiring inadequately supported |1.9.2a| | 1 |
| Brake hydraulic reservoir leaking hydraulic fluid |3.6.A.1| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Nearside Front Leaf spring anchor bracket loose |2.4.B.6a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |