| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 12 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 10 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 5 |
| Rear parking brake recording little or no effort | 4 |
| Indicator tell tale inoperative |1.4.A.2a| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 3 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
| Registration plate issues | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Brake pedal has insufficient reserve travel |1.1.2 |a|| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Service brake: efficiency below requirements |3.7.D.4| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Front brake application uneven | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Horn not working (7.7 (a)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Exhaust emissions hydrocarbon content excessive |8.2.1.2 |b|| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded door sill |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Steering column fractured (2.1.3 (c) (i)) | 1 |
| Nearside Front Anti-roll bar insecurely attached locking device not effective (5.3.3 (a) (i)) | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear Macpherson strut insecure |2.4.G.1| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Horn not working switch missing |7.7 |a| |ii|| | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
| Nearside Rear Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Nearside Obligatory mirror missing and interior (3.3 (a)) | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced floor to sill central area (7.1.1 (a) (i)) | 1 |
| Boot lid cannot be secured in the closed position (6.2.1 (e)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Integral body structure has excessive corrosion which adversely affects braking or steering floor and floor to sill (6.1.1 (c) (ii)) | 1 |
| Front Integral body structure has excessive corrosion which adversely affects braking or steering both side floor hold (6.1.1 (c) (ii)) | 1 |
| Front Boot lid cannot be secured in the closed position (6.2.1 (e)) | 1 |
| Rear Service brake effort inadequate at a wheel both sides (1.2.1 (a) (i)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension weakened allowing body or other component to foul a road wheel or would do so if laden |2.4.A.1b| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Registration plate lamp issues | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Lower Steering column universal joint insecure |2.1.5| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Brake pipe excessively corroded | 1 |