| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 17 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 15 |
| Brake hose excessively deteriorated | 14 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 12 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 10 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
| Brake pipe excessively corroded | 8 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 6 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Brakes imbalanced across an axle | 6 |
| Rear brake application uneven | 6 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Registration plate lamp issues | 4 |
| Rear parking brake recording little or no effort | 4 |
| Offside front brake binding |3.7.B.1| | 3 |
| Horn not working |1.6.2a| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear brake binding | 2 |
| Exhaust engine idle speed too high |7.3.D.1| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Steering column top mounting bracket insecure |2.1.2d| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Registration plate issues | 2 |
| Nearside Rear Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 2 |
| Offside Front Brake hose excessively twisted rubbing (1.1.12 (b) (ii)) | 2 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Nearside Front Outer Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Offside Front Outer Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Offside Front Inner Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Front brake application uneven | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Offside Front Steering system fouling |2.2.D.2a| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer box |7.1.2| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Rear Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Battery insecure |1.9.1| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Brake hose damaged | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Nearside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Offside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Windscreen has damage | 1 |
| Offside Rear Stop lamp insecure |1.2.1a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Seat belt anchorage prescribed area is deliberately modified which significantly reduces the original strength |5.2.6| | 1 |
| Nearside Rear Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Outer Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp aim beam image too far to the left |1.6.B4| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Rear Body has a projection caused by damage |6.1.C.1| | 1 |
| Offside Rear Coil spring not correctly located |2.4.C.2| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering floor holed |6.1.A.1| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Closing point (5.3.6 (a) (i)) | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Closing point (5.3.6 (a) (i)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |