Most common failures | No# failures |
---|
Registration plate lamp issues | 17 |
Brake pipe excessively corroded | 12 |
Windscreen wiper does not clear the windscreen effectively | 12 |
Parking brake: efficiency below requirements |3.7.C.1b| | 10 |
Headlamp aim out of alignment | 7 |
Parking brake lever has no reserve travel |3.1.6b| | 6 |
Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
Offside Rear Stop lamp not working |1.2.1b| | 5 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Parking brake: efficiency below requirements |3.7.B.7| | 4 |
Offside Stop lamp not working |1.2.1b| | 4 |
Rear parking brake recording little or no effort | 4 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 3 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
Rear brake disc in such a condition that it is seriously weakened | 3 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Rear brake binding | 2 |
Offside Steering rack gaiter insecure |2.2.D.2d| | 2 |
Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
Nearside Rear Subframe mounting prescribed area is inadequately repaired chassis / floor (5.3.6 (a) (i)) | 2 |
Registration plate issues | 2 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Front Upper Macpherson strut pin or bush excessively worn |5.3.4 |a| |i|| | 2 |
Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
Rear fog lamp insecure |1.3.2a| | 2 |
Rear fog lamp not working |1.3.2b| | 2 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Headlamp aim so that beam "kick up" is not visible on the screen |1.8.B.1| | 1 |
Supplementary Restraint System warning lamp indicates a fault air bag warning light on |5.4.2| | 1 |
Rear Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
Nearside Rear coil spring broken at top |2.4.C.1a| | 1 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Centre mounting |6.1.B.2| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings centre inner sill |6.1.B.2| | 1 |
Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Inner Drive shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
Nearside Rear Lower Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Brake cable has restricted free movement |3.5.1k| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Offside Rear fog lamp not working |1.3.2b| | 1 |
Nearside Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Front Headlamp not working on dipped beam n/s and o/s |4.1.1 |a| |ii|| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner and outer sill |5.3.6 |a| |i|| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Front Power steering ram|s| leaking from a failed seal |2.3.3b| | 1 |
Rear Brake relay lever has restricted free movement |3.5.1k| | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Nearside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Exhaust fumes causing a danger to health of persons on board (6.1.2 (b) (ii)) | 1 |
Exhaust has a major leak of exhaust gases front flex (6.1.2 (a)) | 1 |
Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Rear Brake pivot has restricted free movement (1.1.15 (e)) | 1 |
Nearside Rear Seat belt missing buckle (7.1.2 (a)) | 1 |
Offside Rear Seat belt missing buckle (7.1.2 (a)) | 1 |
Central Rear Seat belt missing 2nd buckle (7.1.2 (a)) | 1 |
Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings cross member |6.1.B.2| | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
Brake performance not tested (1.2.1 (g)) | 1 |
Nearside Front All position lamps not working |1.1.A.3b| | 1 |
Offside Front All position lamps not working |1.1.A.3b| | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction sun visor wont stay in upright position (3.1 (a) (ii)) | 1 |
Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Nearside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength chassis / floor (5.3.6 (a) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis/ floor (5.3.6 (a) (i)) | 1 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Exhaust has a major leak of exhaust gases front flexy |7.1.2| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength chassis /floor (5.3.6 (a) (i)) | 1 |
Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength chassis/ floor (5.3.6 (a) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis / floor (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis / floor (5.3.6 (a) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area is inadequately repaired chassis / floor (5.3.6 (a) (i)) | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
Speedometer clearly inoperative |7.8 |b| |ii|| | 1 |
Nearside Rear Brake cable has restricted free movement |1.1.15 |e|| | 1 |
Offside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front Brake hose twisted |3.6.B.4c| | 1 |
Offside Front Upper Suspension arm ball joint excessively worn As marked. (5.3.4 (a) (i)) | 1 |
Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Front Prop shaft flexible coupling excessively deteriorated rear joint, on front driveshaft to front axle (6.1.7 (d) (i)) | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Nearside Side repeater incorrect colour |4.4.3 |a|| | 1 |
Offside Side repeater incorrect colour |4.4.3 |a|| | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Brakes imbalanced across an axle | 1 |
Front Anti-roll bar rubber bush deteriorated resulting in excessive movement both n/s o/s [D] bushes worn |2.4.G.2| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Rear Shock absorbers has a serious fluid leak | 1 |
Anti-lock braking system warning lamp indicates an ABS fault | 1 |
Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Nearside Front Headlamp incorrect colour |4.1.4 |a|| | 1 |
Nearside Rear Axle fractured Braket |5.1.1 |a|| | 1 |
Nearside Front Suspension arm ball joint excessively worn upper (5.3.4 (a) (i)) | 1 |
Offside Front Suspension arm ball joint excessively worn upper (5.3.4 (a) (i)) | 1 |
Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sillbacking (6.2.2 (d) (i)) | 1 |
Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill backing (6.2.2 (d) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength backing sill (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength backing sill (5.3.6 (a) (i)) | 1 |
Nearside Front coil spring broken |2.4.C.1a| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Brake lever has insufficient reserve travel handbrake |1.1.2 |a|| | 1 |
Rear Service brake juddering severely |3.7.C.2| | 1 |
Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Nearside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill corroded |6.2.2 |d| |i|| | 1 |
Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill corroded |6.2.2 |d| |i|| | 1 |
Offside Rear Inner Body panel corroded and likely to cause injury sill corroded |6.2.1 |a| |i|| | 1 |
Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Rear Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill |6.1.1 |c| |i|| | 1 |
Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill |6.1.1 |c| |i|| | 1 |
Front Anti-roll bar pin or bush excessively worn d bushes |5.3.4 |a| |i|| | 1 |
Nearside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
Offside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
Nearside Front Lower Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Rear Anti-roll bar fractured |2.4.G.1| | 1 |
Nearside Rear Upper coil spring broken |2.4.C.1a| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Rear Anti-roll bar fractured at the o/s `D` bush mounting |2.4.G.1| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Windscreen wiper blade insecure | 1 |
Rear Brake pivot has restricted free movement |3.5.1k| | 1 |
Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Offside Rear Torque/reaction arm has excessive play in a ball joint |2.4.G.2| | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |