| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 27 |
| Windscreen wiper does not clear the windscreen effectively | 21 |
| Registration plate lamp issues | 18 |
| Registration plate issues | 10 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 10 |
| Brake hose excessively deteriorated | 7 |
| Rear parking brake recording little or no effort | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Battery insecure |1.9.1| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Brakes imbalanced across an axle | 4 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Windscreen has damage | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 3 |
| Rear fog lamp missing |1.3.2a| | 3 |
| Rear brake binding | 3 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Offside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 2 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
| Rear fog lamp switch missing |1.3.1a| | 2 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Windscreen wiper blade insecure | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Offside Front Brake hose twisted |3.6.B.4c| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
| Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Side repeater missing both sides (4.4.1 (a) (ii)) | 1 |
| Rear Direction indicator incorrect colour both sides (4.4.3 (a)) | 1 |
| Central Rear Statutory seat belt missing buckle |5.1.1| | 1 |
| Offside Rear Statutory seat belt missing buckle |5.1.1| | 1 |
| Nearside Outer Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Outer Rear Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Outer Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Steering column universal joint fractured to the extent that steering is affected (2.1.3 (c) (ii)) | 1 |
| Nearside Front Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Offside Front Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Offside Front Headlamp not working on dipped beam intermittently fails (4.1.1 (a) (ii)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Front Steering column universal joint has excessive wear or play (2.2.2 (c)) | 1 |
| Nearside Front Position lamp switch does not illuminate the front and rear position lamps with a single operation (4.2.2 (a)) | 1 |
| Offside Front Position lamp switch does not illuminate the front and rear position lamps with a single operation (4.2.2 (a)) | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Rear fog lamp switch insecure |1.3.1a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Upper Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Anti-roll bar linkage has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Offside Front Front drive shaft coupling is excessively worn |2.5.C.1c| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Steering damper leaking oil |2.2.C.1f| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Brake hose damaged | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Rear Upper Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear fog lamp missing not fitted |1.3.2a| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp|s| remains on when the brakes are released |4.3.2 |a| |iii|| | 1 |
| Offside Front Outer Drive shaft joint excessively worn |6.1.7 |c| |i|| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Rear Seat belt installation has a seat fitted to a flat rail and the mounting bolt not passing through the leg, rail, floor, and a suitable structural member (10.1 (p)) | 1 |
| Offside Front Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Nearside Front Anti-roll bar linkage missing |2.4.G.1| | 1 |
| Offside Front Anti-roll bar linkage missing |2.4.G.1| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Offside Front Outer Drive shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Obligatory mirror missing |3.3 |a|| | 1 |
| Nearside Stop lamp|s| adversely affected by the operation of another lamp |4.3.3 |b|| | 1 |
| Oil leaking excessively from transmission coolant radiator area |8.4.1 |a| |i|| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Fuel cap/sealing device ineffective |6.1.3 |b| |i|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Drivers seat moving inadvertently (6.2.5 (b) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Central Front Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Front Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Central Rear Stop lamp not working |1.2.1b| | 1 |
| Central Rear Upper Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Lower Shock absorbers insecurely attached bolt loose (5.3.2 (a) (i)) | 1 |
| Offside Rear Lower Shock absorbers insecurely attached bolt loose (5.3.2 (a) (i)) | 1 |
| Offside Front drive shaft coupling is excessively worn |2.5.C.1c| | 1 |
| Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
| Rear fog lamp switch missing |4.5.3 |a| |ii|| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt on to steering box (2.1.3 (g) (ii)) | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Rear Body mounting fixings missing rubber missing (6.2.2 (c) (i)) | 1 |
| Offside Rear Body mounting fixings missing rubber missing (6.2.2 (c) (i)) | 1 |
| Nearside Body mounting fixings insecure middle (6.2.2 (c) (i)) | 1 |
| Offside Body mounting fixings insecure middle (6.2.2 (c) (i)) | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Front Anti-roll bar insecure |2.4.G.1| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Rear Anti-roll bar linkage synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Seat belt affected by a damaged seat frame |5.2.1b| | 1 |
| Offside Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Central Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Offside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Rear Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |