| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 494 |
| Headlamp aim out of alignment | 313 |
| Registration plate lamp issues | 311 |
| Windscreen wiper does not clear the windscreen effectively | 300 |
| Registration plate issues | 180 |
| Brakes imbalanced across an axle | 164 |
| Nearside Stop lamp not working |1.2.1b| | 86 |
| Offside Stop lamp not working |1.2.1b| | 84 |
| Parking brake: efficiency below requirements |3.7.B.7| | 78 |
| Offside Rear fog lamp not working |1.3.2b| | 77 |
| Rear parking brake recording little or no effort | 76 |
| Centre Stop lamp not working |1.2.1b| | 54 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 54 |
| Rear fog lamp not working |1.3.2b| | 53 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 52 |
| Rear Exhaust system not adequately supported |7.1.1| | 46 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 45 |
| Service brake: efficiency below requirements |3.7.B.7| | 42 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 42 |
| Rear brake application uneven | 42 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 42 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 41 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 40 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 38 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 36 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 36 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 34 |
| Horn not working |1.6.2a| | 34 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 33 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 31 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 31 |
| Battery insecure |1.9.1| | 30 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 27 |
| Windscreen washer not working | 27 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 26 |
| Nearside Rear Stop lamp not working |1.2.1b| | 25 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 24 |
| Windscreen has damage | 23 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 23 |
| Parking brake lever has no reserve travel |3.1.6b| | 23 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 21 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 20 |
| Front brake disc in such a condition that it is seriously weakened | 20 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 20 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 19 |
| Front Steering damper leaking oil |2.2.C.1f| | 19 |
| Offside Rear Stop lamp not working |1.2.1b| | 19 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 18 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 18 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 17 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 16 |
| Rear brake binding | 16 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 16 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 15 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 15 |
| Brake hose excessively deteriorated | 15 |
| Hazard warning switch faulty |1.4.B.1d| | 15 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 15 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 15 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 15 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 15 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 15 |
| Emissions not tested |7.0| | 15 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 15 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 15 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 15 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 14 |
| Exhaust system not adequately supported |7.1.1| | 14 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 14 |
| Windscreen wiper blade insecure | 14 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 14 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 14 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 14 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 14 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 14 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 14 |
| Offside Front brake disc excessively pitted |3.5.1h| | 13 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 13 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 13 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 13 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 13 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 13 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 13 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 13 |
| Stop lamp not working |1.2.1b| | 13 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 13 |
| Steering damper leaking oil |2.2.C.1f| | 12 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 12 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 12 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 12 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 12 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 12 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 12 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 12 |
| Nearside Side repeater not working |1.4.A.2c| | 12 |
| Offside Headlamp not working on main beam |1.7.5a| | 12 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 11 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 11 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 11 |
| Offside Front drive shaft coupling is excessively worn |2.5.C.1c| | 11 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 11 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 11 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 11 |
| Nearside Headlamp not working on main beam |1.7.5a| | 11 |
| Centre Rear Stop lamp not working |1.2.1b| | 11 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 10 |
| Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 10 |
| Offside Front Front drive shaft coupling is excessively worn |2.5.C.1c| | 10 |
| Rear Rear fog lamp not working |1.3.2b| | 10 |
| Horn not working (7.7 (a)) | 10 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 10 |
| Offside Front Direction indicator not working |1.4.A.2c| | 10 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 10 |
| Rear Mechanical brake component has restricted free movement | 10 |
| Offside Rear Braking system leaking |3.6.A.1| | 10 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 10 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 10 |
| Offside Side repeater not working |1.4.A.2c| | 10 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 9 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 9 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 9 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 9 |
| Windscreen wiper not working (3.4 (a)) | 9 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 9 |
| Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 9 |
| Offside Rear fog lamp missing |1.3.2a| | 9 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 9 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 9 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 9 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 9 |
| Offside front brake binding |3.7.B.1| | 9 |
| Nearside Front drive shaft coupling is excessively worn |2.5.C.1c| | 9 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 9 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 9 |
| Rear fog lamp tell tale not working |1.3.1b| | 9 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 8 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 8 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 8 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 8 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 8 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 8 |
| Power steering component|s| leaking |2.3.3b| | 8 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 8 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 8 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 8 |
| Nearside Rear Braking system leaking |3.6.A.1| | 8 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 8 |
| Stop lamp remains on when the brakes are released | 8 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 8 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 8 |
| Front brake application uneven | 8 |
| Direction indicators not working |1.4.A.2c| | 8 |
| Offside Front Side repeater not working |1.4.A.2c| | 8 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 8 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 8 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 8 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 7 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 7 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 7 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 7 |
| Service brake: efficiency below requirements |3.7.C.1a| | 7 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| All direction indicators not working (4.4.1 (a) (ii)) | 7 |
| Brake performance not tested (1.2.1 (g)) | 7 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 7 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 7 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 7 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 7 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 7 |
| Offside Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 7 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 7 |
| Nearside Rear brake drum contaminated by oil |3.5.1h| | 7 |
| Steering box has a significant oil leak |2.2.D.2e| | 7 |