| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 7 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Brake pipe excessively corroded | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
| Registration plate lamp issues | 2 |
| Horn not working |1.6.2a| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Horn not working (7.7 (a)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Windscreen wiper blade insecure | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Rear Direction indicator lens defective such that the emitted light is adversely affected |4.4.1 |b| |ii|| | 1 |
| Nearside Rear Stop lamp|s| lens defective such that the emitted light is adversely affected |4.3.1 |b| |ii|| | 1 |
| Offside Front Suspension arm attachment bracket/mounting insecure |5.3.3 |a| |i|| | 1 |
| Offside Front Body panel damaged and likely to cause injury |6.2.1 |a| |i|| | 1 |
| Nearside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Front Suspension arm locating pin insecure |2.4.G.3a| | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) & steering feels notchy (2.3 (a) (i)) | 1 |
| Nearside Front Drivers seat insecure Both right hand frame bolts not fully seated leaving frame a loose attachment (6.2.5 (a) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Semaphore indicator arm arm does not show an amber light to the rear |1.4.C.1b| | 1 |
| Offside Semaphore indicator arm arm does not show an amber light to the rear |1.4.C.1b| | 1 |
| Offside Track rod end loose |2.2.B.1d| | 1 |
| Registration plate issues | 1 |
| Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Rear Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Offside Rear Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Nearside Front Road wheel cracked |4.2.A.1a| | 1 |
| Offside Front Road wheel cracked |4.2.A.1a| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Brake pipe inadequately clipped Across Rear Axle |3.6.B.1| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded Around Shackle Pin |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is severely distorted Around Shackle Pin |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is severely distorted Around Shackle Pin |2.4.A.3| | 1 |
| Front position lamp|s| incorrect colour Both |1.1.A.3e| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Stop lamp|s| light intensity significantly reduced |4.3.3 |a| |ii|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Anti-roll bar linkage insecurely attached |5.3.3 |a| |i|| | 1 |
| Nearside Front Anti-roll bar linkage missing |5.3.3 |a| |ii|| | 1 |
| Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
| Direction indicator adversely affected by the operation of another lamp both sides rear (4.4.3 (b)) | 1 |
| Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Centre Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear fog lamp switch not able to be operated from the normal driving position |1.3.1a| | 1 |
| Nearside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Drag link end ball pin shank loose |2.2.B.1c| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Headlamp aim projected beam image is obviously incorrect both sides |4.1.2 |c|| | 1 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Hazard warning switch inoperative Missing (4.4.2 (a) (ii)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Power steering pump leaking (2.1.5 (a)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Rear Rear fog lamp switch missing |1.3.1a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |