| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 24 |
| Registration plate lamp issues | 17 |
| Headlamp aim out of alignment | 16 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 15 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 9 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Anti-lock braking system warning lamp indicates an ABS fault | 7 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 5 |
| Windscreen washer not working | 4 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 4 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Offside Front Shock absorbers has a serious fluid leak | 3 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 3 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 3 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 3 |
| Offside Front Position lamp not working |4.2.1 |a|| | 3 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Rear parking brake recording little or no effort | 2 |
| Brake fluid contaminated (1.8 (a)) | 1 |
| Emissions not tested Excessive smoke when accelerating, emissions test aborted (8.2.2.2 (e)) | 1 |
| Oil leaking excessively from transmission (8.4.1 (a) (i)) | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Rear Boot lid insecure (6.2.1 (a) (i)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Central Front Fuel system component leaking |7.2.3| | 1 |
| Nearside Rear Fuel cap/sealing device mounting flange/sealing method defective could not remover the cap for inspection |7.2.4c| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Front Service brake juddering severely |3.7.C.2| | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Brake performance not tested due to binding brakes (1.2.1 (g)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Central Rear Seat belt buckle missing jammed under seat (7.1.2 (d)) | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Front Valve stem seriously damaged |5.2.3 |j|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Service brake juddering severely |3.7.C.2| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Front Electrical wiring insecure Tow bar wiring. |1.9.2a| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release seatbelt stalk |5.2.5a| | 1 |
| Electronic stability control warning lamp indicates a fault |7.12 |e|| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Parking brake lever inoperative (1.1.6 (d)) | 1 |
| Front Position lamp not working BOTH SIDES (4.2.1 (a) (ii)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn both rear D bushs (5.3.4 (a) (i)) | 1 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired control arm mount (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength pan arm rod mounting point (5.3.6 (a) (i)) | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Lower Anti-roll bar ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Front Bumper likely to become detached damaged and broken |6.1.4 |a| |ii|| | 1 |
| Parking brake lever ratchet mechanism worn to the extent that the brake may inadvertently release (1.1.6 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Seat belt flexible stalk damaged likely to lead to failure under load |5.2.4a| | 1 |
| Offside Rear Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Rear Seat belt buckle not functioning as intended By tailgate-- stalk locking mechanism will not accept buckle as intended (7.1.2 (d)) | 1 |
| Trailer electrical socket (13 pin) not operating the trailer lamps as intended offside position lamp and offside indicator (4.10 (c) (i)) | 1 |
| Offside Rear Lower Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Lower Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Offside Front Lower Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Nearside Front Lower Battery insecure |1.9.1| | 1 |
| Nearside Front Lower Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Lower front brake binding |3.7.B.1| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt wishbone (5.3.4 (b) (ii)) | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Front Lower Suspension arm ball joint excessively worn ball joint both sides (5.3.4 (a) (i)) | 1 |
| Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Parking brake lever has excessive side play in the pivot and may disengage |3.1.4a| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Trailer electrical socket likely to become detached (4.10 (a) (ii)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced at sill (7.1.1 (a) (i)) | 1 |
| Windscreen has damage | 1 |
| Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Window in an unacceptable condition (3.2 (c) (i)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Front Anti-lock braking system wiring excessively damaged |3.4.3| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |