| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 24 |
| Headlamp aim out of alignment | 24 |
| Windscreen wiper does not clear the windscreen effectively | 18 |
| Brake pipe excessively corroded | 16 |
| Registration plate issues | 9 |
| Anti-lock braking system warning lamp indicates an ABS fault | 8 |
| Rear parking brake recording little or no effort | 7 |
| Battery insecure |1.9.1| | 6 |
| Brake hose excessively deteriorated | 6 |
| Brakes imbalanced across an axle | 5 |
| Centre Stop lamp not working |1.2.1b| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Rear brake application uneven | 4 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Horn not working (7.7 (a)) | 2 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Front coil spring fractured |2.4.C.1a| | 2 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Seat belt anchorage prescribed area strength or continuity significantly reduced both sides outer sills |7.1.1 |a| |i|| | 1 |
| Central Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Seat belt anchorage prescribed area is inadequately repaired sill end (7.1.1 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced sill backing (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced sill backing (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced sill backing at side step mounts (7.1.1 (a) (i)) | 1 |
| Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced center sill backing (6.1.1 (c) (i)) | 1 |
| Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced center sill backing (6.1.1 (c) (i)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Exhaust has a major leak of exhaust gases rear (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Central Rear Seat belt webbing significantly weakened |7.1.2 |b| |ii|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill |7.1.1 |a| |i|| | 1 |
| Nearside Rear Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
| Service brake juddering severely |3.7.C.2| | 1 |
| Windscreen wiper blade insecure | 1 |
| Rear brake binding | 1 |
| Windscreen has damage | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Front brake application uneven | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Upper Axle swivel joint has excessive play in a ball joint |2.5.A.3b| | 1 |
| Offside Lower Axle swivel joint has excessive play in a ball joint |2.5.A.3b| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Centre Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Inner Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Outer Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Outer Prop shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Offside Outer Front drive shaft coupling is excessively worn |2.5.C.1c| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Windscreen washer not working | 1 |
| Brake fluid contaminated (1.8 (a)) | 1 |
| Offside Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Brake pipe kinked |3.6.B.2b| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Centre Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Centre Upper Stop lamp not working |1.2.1b| | 1 |
| Rear Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Upper Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Upper Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear Upper Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Upper Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Offside brake disc in such a condition that it is seriously weakened |3.5.1i| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Outer Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Nearside Front Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Fuel tank insecure one strap broken |7.2.1| | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced center to rear outer and under sill |7.1.1 |a| |i|| | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced center to rear outer and under sill |7.1.1 |a| |i|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill |7.1.1 |a| |i|| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill |7.1.1 |a| |i|| | 1 |
| Steering component deformed to the extent that steering is affected steering damper excessively leaking |2.1.3 |c| |ii|| | 1 |
| Emissions not tested due to system leaking |8.2.1.2 |d|| | 1 |
| Emission control equipment missing where fitted as standard silencers |8.2.1.1 |a|| | 1 |
| Exhaust has a major leak of exhaust gases center to rear multiple areas |6.1.2 |a|| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |8.1.1 |a|| | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Fluid leaking continuously posing a serious risk to road safety anti-freeze |8.4.1 |a| |ii|| | 1 |
| Towbar with an unsafe modification to primary components corroded |6.1.6 |g| |ii|| | 1 |
| Nearside Rear Leaf spring shackle bracket corroded and seriously weakened rear |5.3.1 |b| |i|| | 1 |
| Offside Rear Leaf spring shackle bracket corroded and seriously weakened |5.3.1 |b| |i|| | 1 |
| Nearside Rear Leaf spring main leaf fractured front spring eye corroded and deformed |5.3.1 |b| |ii|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength leaf spring and tow bar mounting area |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength leaf spring and tow bar mounting area |5.3.6 |a| |i|| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Nearside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Seat belt not functioning as intended receiver not locking |7.1.2 |c|| | 1 |
| Nearside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Lower Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
| Offside Front Upper Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Rear brake disc contaminated by oil |3.5.1h| | 1 |
| Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front drive shaft coupling is excessively worn |2.5.C.1c| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Nearside Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Offside Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Nearside Front Front position lamp|s| not working connection |1.1.A.3b| | 1 |
| Offside Front Front drive shaft coupling is excessively worn |2.5.C.1c| | 1 |
| Nearside Front Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Offside Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Headlamp lens seriously defective both (4.1.1 (b) (ii)) | 1 |
| Rear Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Vehicle structure is deformed and structural rigidity is significantly reduced near side rear sill not wielded (6.1.1 (a) (i)) | 1 |
| Power steering component leaking damper (2.1.5 (a)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Offside Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Upper Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Offside Front Obligatory mirror insecure |8.1.1| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Lower Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Outer Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Inner Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |