| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 18 |
| Windscreen wiper does not clear the windscreen effectively | 17 |
| Registration plate lamp issues | 15 |
| Brake pipe excessively corroded | 8 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Brakes imbalanced across an axle | 6 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Registration plate issues | 3 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Offside Front Front drive shaft coupling is excessively worn |2.5.C.1c| | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 3 |
| Horn not working |1.6.2a| | 3 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Nearside Front drive shaft coupling is excessively worn |2.5.C.1c| | 2 |
| Offside Front drive shaft coupling is excessively worn |2.5.C.1c| | 2 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Steering system excessively tight |2.2.D.1| | 2 |
| Power steering malfunctioning |2.3.3a| | 2 |
| Windscreen has damage | 2 |
| Offside Front brake disc excessively scored |3.5.1h| | 2 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Rear brake binding | 2 |
| Rear brake application uneven | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| All position lamps not working |1.1.A.3b| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Offside Front Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Anti-roll bar missing |2.4.G.1| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Offside Rear Lower Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Lower Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outer sill |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outer sill |6.1.B.2| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings back of sill + floor |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings back of sill |6.1.B.2| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Rear Service brake application uneven across the axle no effort nearside & offside |3.7.D.2b| | 1 |
| Offside Front Upper Shock absorber insecure |2.7.2b| | 1 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded middle sill |5.2.6| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
| Emissions not tested |7.4.B.1| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength Behind Leaf Spring (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength In Front of Leaf Spring (5.3.6 (a) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Anti-roll bar linkage damaged and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area is inadequately repaired (7.1.1 (a) (i)) | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside brake disc in such a condition that it is seriously weakened |3.5.1i| | 1 |
| Nearside Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp flickers when tapped lightly by hand |1.2.4c| | 1 |
| Offside Rear Upper Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Upper Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Horn not a continuous or uniform sound |1.6.2e| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Offside Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Offside Outer Front Front drive shaft coupling has excessive play in a universal joint bearing |2.4.G.6b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Front Anti-roll bar missing |2.4.G.1| | 1 |
| Offside Front Anti-roll bar linkage missing |2.4.G.1| | 1 |
| Nearside Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Fuel system component leaking |7.2.3| | 1 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Trailer electrical socket (13 pin) not functioning at all (4.10 (c) (ii)) | 1 |
| Hazard warning switch inoperative switch missing (4.4.2 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Suspension component corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting ( osf seat ) (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting ( osf spring hanger ) (6.2.2 (d) (i)) | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Emissions not tested low fuel |7.3.A.1| | 1 |
| Nearside Stop lamp missing |1.2.1a| | 1 |
| Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
| Offside Rear Leaf spring damaged and permanently distorted |2.4.B.1a| | 1 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Inner Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |