Most common failures | No# failures |
---|
Brake pipe excessively corroded | 46 |
Headlamp aim out of alignment | 31 |
Parking brake: efficiency below requirements |3.7.B.7| | 26 |
Rear parking brake recording little or no effort | 21 |
Registration plate lamp issues | 19 |
Parking brake: efficiency below requirements |3.7.C.1b| | 17 |
Windscreen wiper does not clear the windscreen effectively | 15 |
Parking brake lever has no reserve travel |3.1.6b| | 14 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 13 |
Anti-lock braking system warning lamp indicates an ABS fault | 12 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 7 |
Rear brake binding | 7 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 5 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Front brake disc in such a condition that it is seriously weakened | 5 |
Rear Exhaust system not adequately supported |7.1.1| | 4 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
Offside Stop lamp not working |1.2.1b| | 3 |
Nearside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 3 |
Offside Front brake disc excessively pitted |3.5.1h| | 3 |
Brake hose damaged | 3 |
Brakes imbalanced across an axle | 3 |
Registration plate issues | 3 |
Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 3 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Offside Front coil spring fractured |2.4.C.1a| | 2 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Front front brake binding |3.7.B.1| | 2 |
Offside Rear brake caliper has restricted free movement |3.5.1k| | 2 |
Rear fog lamp tell tale not working |1.3.1b| | 2 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Rear Stop lamp not working |1.2.1b| | 2 |
Offside Front coil spring incomplete |2.4.C.1a| | 2 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Battery insecure |1.9.1| | 2 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Front coil spring incomplete |2.4.C.1a| | 2 |
Service brake: efficiency below requirements |3.7.C.1a| | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
Brake hose has insufficient room to move | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Rear Exhaust system not adequately supported |7.1.1| | 2 |
Offside Rear fog lamp not working |1.3.2b| | 2 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Rear wheel bearing has excessive play |2.6.2| | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Outer Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
Offside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Brake hose excessively deteriorated | 1 |
Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Outer Front Headlamp insecure |1.7.3| | 1 |
Nearside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Offside Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
Offside Front Body panel corroded and likely to cause injury wing (6.2.1 (a) (i)) | 1 |
Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front Lower Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
Nearside Front Lower Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front coil spring broken |2.4.C.1a| | 1 |
Offside Front Headlamp has a product on the light source so that the light output is severely reduced no beam pattern. (4.1.4 (b)) | 1 |
Offside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner floor holed within 30cm. (7.1.1 (a) (i)) | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Bonnet primary retaining device excessively deteriorated |3.1 |c|| | 1 |
Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Anti-roll bar pin or bush excessively worn offside and nearside rear bushes (5.3.4 (a) (i)) | 1 |
Seat belt anchorage prescribed area strength or continuity significantly reduced offside and nearside outer sills in front belt mounting areas (7.1.1 (a) (i)) | 1 |
Suspension component mounting prescribed area excessively corroded significantly reducing structural strength offside and nearside outer sills at rear in mounting areas (5.3.6 (a) (i)) | 1 |
Nearside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Centre Stop lamp not working |1.2.1b| | 1 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings nearside and offside sills |6.1.B.2| | 1 |
Fuel system component leaking fuel filter |7.2.3| | 1 |
Offside Rear Lower Trailing arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Rear Sub-frame attachment bracket/mounting cracked |2.4.G.1| | 1 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
Suspension component mounting prescribed area is excessively corroded Both side outer sills |2.4.A.3| | 1 |
Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded Sill |2.4.A.3| | 1 |
Offside Inner Suspension component mounting prescribed area is excessively corroded Sill |2.4.A.3| | 1 |
Nearside Rear Suspension arm severely distorted |2.4.G.1| | 1 |
Rear Anti-roll bar has excessive play in a pin/bush Both side stable on anti roll bar |2.4.G.2| | 1 |
Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt Both side |2.4.G.2| | 1 |
Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
Offside Front Braking system leaking Caliper |3.6.A.1| | 1 |
Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
Parking brake lever ratchet not holding correctly (1.1.6 (a)) | 1 |
Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Rear Exhaust has a part missing |7.1.1a| | 1 |
Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outter sill |6.1.B.2| | 1 |
Offside Outer Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
Offside Front Lower Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front coil spring fractured |2.4.C.1a| | 1 |
Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Offside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Headlamp aim not tested |1.8.A.1c| | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Windscreen washer not working | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Coil spring mounting damaged and seriously weakened |2.4.C.3c| | 1 |
Emissions not tested |7.0| | 1 |
Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Rear Subframe mounting prescribed area is excessively corroded chassis leg corroded |2.4.A.3| | 1 |
Offside Outer Subframe mounting prescribed area is excessively corroded sill corroded |2.4.A.3| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded underfloor sill corroded |5.2.6| | 1 |
Offside Outer Seat belt anchorage prescribed area is excessively corroded underfloor sill corroded |5.2.6| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
Brake pipe leaking |3.6.A.1| | 1 |
Nearside Front Lower Body has a sharp edge caused by corrosion wing |6.1.C.1| | 1 |
Offside Front Lower Body has a sharp edge caused by corrosion wing |6.1.C.1| | 1 |
Nearside Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
Offside Front Brake pipe leaking |3.6.A.1| | 1 |
Horn not working |1.6.2a| | 1 |
Offside Inner Rear brake disc excessively pitted |3.5.1h| | 1 |
Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
Offside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Front Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
Nearside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Emissions not tested |7.3.A.1| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front Bootlid cannot be secured in the closed position |6.4.1| | 1 |
Offside Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
Offside Rear Brake pipe leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
Offside Rear Exhaust system insecure |6.1.2 |a|| | 1 |
Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Central Rear Statutory seat belt missing |5.1.1| | 1 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Nearside Rear Seat belt damaged (7.1.2 (b) (i)) | 1 |
Offside Front Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Nearside Rear Inner Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Offside Rear Inner Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Nearside Rear Inner Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
Offside Rear Lower Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Windscreen has damage | 1 |
Nearside Front Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Headlamp aim headlamp not in good working order adversely affecting beam image |1.2.4b| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Offside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Rear Inner Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear Outer Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Rear Outer Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Nearside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded Inner sill and f;oor |5.2.6| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded Inner sill and floor |5.2.6| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
Front Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
Front rear brake excessively fluctuating |3.7.B.3| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Nearside Front Headlamps matched pair are not the same colour |1.7.6| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Rear Road wheel badly damaged |4.2.A.1a| | 1 |