| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 76 |
| Brake pipe excessively corroded | 56 |
| Parking brake: efficiency below requirements |3.7.B.7| | 45 |
| Headlamp aim out of alignment | 34 |
| Service brake: efficiency below requirements |3.7.B.7| | 27 |
| Brakes imbalanced across an axle | 24 |
| Rear parking brake recording little or no effort | 23 |
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Rear brake binding | 13 |
| Offside Rear fog lamp not working |1.3.2b| | 12 |
| Battery insecure |1.9.1| | 8 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Registration plate issues | 7 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 6 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 6 |
| Horn not working |1.6.2a| | 6 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 6 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Windscreen has damage | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Emissions not tested |7.0| | 4 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Brake load sensing valve seized |3.6.E.3| | 4 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 4 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 4 |
| Front brake application uneven | 4 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 4 |
| Headlamp switch faulty |1.7.1| | 4 |
| Offside front brake binding |3.7.B.1| | 4 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Horn not working |7.7 |a| |ii|| | 3 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 3 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 3 |
| All position lamps not working |1.1.A.3b| | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Offside Rear reflector missing |1.5.1a| | 3 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Horn not working (7.7 (a)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 3 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Rear brake caliper has restricted free movement |3.5.1k| | 2 |
| Steering rack insecure |2.2.B.1a| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Brake load sensing valve inoperative but ABS functioning (1.1.17 (c) (i)) | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Brake pipe inadequately clipped |3.6.B.1| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Brake load sensing valve inoperative |3.6.E.3| | 2 |
| Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 2 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 2 |
| Parking brake: efficiency below requirements |3.7.D.4| | 2 |
| Nearside Rear brake disc contaminated by oil |3.5.1h| | 2 |
| Indicator switch faulty |1.4.A.1| | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 2 |
| Nearside Front Braking system leaking |3.6.A.1| | 2 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Rear brake application uneven | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 2 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| An item not tested |Manual| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Towbar component insecure |6.6.1| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded near front body mount |3.6.C.3| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is fractured |3.6.C.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is fractured chassis cracked through |2.4.A.3| | 1 |
| Nearside Front Leaf spring to axle securing bolt insecure of rear spring |2.4.B.7b| | 1 |
| Nearside Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front Lower Shock absorber insecure |2.7.2b| | 1 |
| Nearside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Front Shock absorber insecure CORRODED OFF CHASSIS LEG |2.7.2b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Brake load sensing valve inoperative linkage broken |3.6.E.3| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear fog lamp has less than 50% of the light sources illuminating |1.3.2b| | 1 |
| Nearside Rear Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |1.8.B.1| | 1 |
| Nearside Front Fuel tank insecure tank strap broken |7.2.1| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Drivers airbag obviously inoperative MIL illuminated (7.1.5 (c)) | 1 |
| Nearside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Front Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
| Nearside All position lamps not working side x 2 |1.1.A.3b| | 1 |
| Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings corroded away |6.1.B.2| | 1 |
| Front Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Rear Lower Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Upper Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Lower Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Inner Lower Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |1.1.21 |e| |i|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wheel arch |6.2.2 |d| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced door sill near door step |7.1.1 |a| |i|| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Service brake effort inadequate at a wheel both sides |1.2.1 |a| |i|| | 1 |
| Offside Rear Leaf spring shackle bracket loose |2.4.B.6a| | 1 |
| Nearside Rear Leaf spring eye defective |anchor| |2.4.B.1b| | 1 |
| Offside Rear Leaf spring eye defective |anchor| |2.4.B.1b| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Upper Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Upper Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings under body chassis |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings body floor to inner wheel arch |6.1.B.2| | 1 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Bonded suspension unit deteriorated and cannot function as intended arm rear bush |2.4.F.3| | 1 |
| Nearside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush rear of spring |2.4.B.2| | 1 |
| Offside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush rear of spring |2.4.B.2| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded inner sill front of wheel |2.4.A.3| | 1 |
| Nearside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 1 |
| Front Power steering component leaking rack (2.1.5 (a)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Brake hose damaged | 1 |
| Offside Front Inner Brake master cylinder/servo mounting prescribed area is excessively damaged Wing/wheel arch (1.1.21 (e) (i)) | 1 |
| Drivers view of the road through the swept area of the windscreen materially affected by an obstruction Stickers (3.1 (a) (ii)) | 1 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Inner Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` Tax disc holder |8.3.1e| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Front Leaf spring cracked |2.4.B.1a| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Offside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Centre Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
| Offside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Offside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Position lamp switch does not illuminate the front and rear position lamps with a single operation |1.1.A.2| | 1 |
| Nearside Brake cable locking device missing |3.5.1l| | 1 |
| Offside Brake cable locking device missing |3.5.1l| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush front |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush front |2.4.B.2| | 1 |
| Nearside Rear Upper Leaf spring has excessive wear in a shackle pin and/or bush rear |2.4.B.2| | 1 |
| Nearside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush rear |2.4.B.2| | 1 |
| Offside Rear Upper Leaf spring has excessive wear in a shackle pin and/or bush rear |2.4.B.2| | 1 |
| Offside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush rear |2.4.B.2| | 1 |
| Central Front Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt swivel |2.4.G.2| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Battery insecure and likely to cause a short circuit in cab |4.13 |a| |ii|| | 1 |
| Brake load sensing valve linkage defective and function impaired |1.1.17 |a|| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
| Oil leaking excessively from engine ENGINE REAR CRANK MAIN OIL SEAL LEAKING |8.4.1 |a| |i|| | 1 |
| Rear Brake load sensing valve inoperative but ABS functioning ON REAR AXLE |1.1.17 |c| |i|| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Centre Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Brake load sensing valve defective and function impaired |3.6.E.3| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
| Offside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Front Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Steering column universal joint has excessive play |2.1.5| | 1 |
| Nearside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Lower Shock absorber detached |2.7.2b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Rear All position lamps have less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Obligatory mirror insecure |8.1.1| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Track rod end loose |2.2.B.1d| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Battery insecure |1.9.1| | 1 |
| Nearside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Leaf spring anchor bracket loose |2.4.B.6a| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Electrical wiring inadequately supported |1.9.2a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner wing / under arch (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting underside box section (6.2.2 (d) (i)) | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Rear Integral body structure inadequately repaired such that structural rigidity is significantly reduced (6.1.1 (d) (i)) | 1 |
| Offside Rear Integral body structure inadequately repaired such that structural rigidity is significantly reduced (6.1.1 (d) (i)) | 1 |
| Steering column attachment defective play in shaft (2.2.2 (d) (i)) | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Leaf spring deteriorated and seriously weakened broken away at shackle mount |2.4.B.1a| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis |5.3.6 |a| |i|| | 1 |
| Bonnet primary retaining device excessively deteriorated (3.1 (c)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Nearside Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Nearside Rear Brake prescribed area is excessively corroded wheel arch corroded and rubbing flexible hose (1.1.21 (e) (i)) | 1 |
| Offside Front Sub-frame corroded and seriously weakened above lower arm mounting (5.3.3 (b) (i)) | 1 |
| Nearside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Rear brake caliper locking device insecure |3.5.1l| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Rear Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength door marked yellow |5.3.6 |a| |i|| | 1 |
| Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill area marked in yellow |6.1.B.2| | 1 |
| Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill area marked in yellow |6.1.B.2| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill in front of and behind wheel (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill in front of wheel (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis outriggers in front of and behind wheel (5.3.6 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Centre Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Rear Anti-roll bar linkage fractured Drop Link Snapped (5.3.3 (b) (ii)) | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Nearside Front Inner Battery insecure and likely to fall from carrier Wing And Battery Tray Excessively Holed And Corroded (4.13 (a) (ii)) | 1 |
| Nearside Rear Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Offside Rear Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Electrical wiring inadequately supported |1.9.2a| | 1 |
| Offside Lower Electrical wiring inadequately supported |1.9.2a| | 1 |
| Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Rear Upper Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Rear Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Upper Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Rear Lower Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded (1.1.21 (e) (i)) | 1 |
| Nearside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |