| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 25 |
| Windscreen wiper does not clear the windscreen effectively | 17 |
| Registration plate lamp issues | 16 |
| Parking brake: efficiency below requirements |3.7.B.7| | 16 |
| Brakes imbalanced across an axle | 11 |
| Headlamp aim out of alignment | 10 |
| Service brake: efficiency below requirements |3.7.B.7| | 8 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Battery insecure |1.9.1| | 5 |
| Rear parking brake recording little or no effort | 5 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Horn not working (7.7 (a)) | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Front brake application uneven | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Brake load sensing valve defective and function impaired |3.6.E.3| | 2 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Bonnet retaining device ineffective |8.4.2| | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear brake caliper has restricted free movement |3.5.1k| | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Windscreen washer not working | 2 |
| Nearside Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting mounting area of body to chassis by front of the rear wheelarch (6.2.2 (d) (i)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Anti-roll bar linkage pin or bush excessively worn both rear |5.3.4 |a| |i|| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Brake load sensing valve seized but ABS functioning |1.1.17 |c| |i|| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Nearside Rear Leaf spring to axle securing bolt insecure u bolts loose |2.4.B.7b| | 1 |
| Offside Rear Leaf spring to axle securing bolt insecure u bolts loose |2.4.B.7b| | 1 |
| Nearside Front Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Centre Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Outer Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn arm |5.3.4 |a| |i|| | 1 |
| Front Horn not working (7.7 (a)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting arch to chassis. (6.2.2 (d) (i)) | 1 |
| Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting arch to chassis. (6.2.2 (d) (i)) | 1 |
| Nearside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting body mount (6.2.2 (d) (i)) | 1 |
| Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting body mount. (6.2.2 (d) (i)) | 1 |
| Central Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting nearside sill. (6.2.2 (d) (i)) | 1 |
| Nearside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill. (6.2.2 (d) (i)) | 1 |
| Offside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill. (6.2.2 (d) (i)) | 1 |
| Nearside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting body mount. (6.2.2 (d) (i)) | 1 |
| Offside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting body mount. (6.2.2 (d) (i)) | 1 |
| Nearside Front Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Brake pipe at imminent risk of failure or fracture |1.1.11 |a|| | 1 |
| Rear Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Lower Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Rear Brake cable has restricted free movement |1.1.15 |e|| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Fuel tank insecure (6.1.3 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases Tail pipe (6.1.2 (a)) | 1 |
| Nearside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Exhaust emits excessive smoke or vapour likely to obscure the vision of other road users |8.2.2.2 |c|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded inner wing and bulkhead area various places (1.1.21 (e) (i)) | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded inner wheel arch area various places (1.1.21 (e) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced step area (7.1.1 (a) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Windscreen has damage | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Sub-frame attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Nearside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings various points |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings at various points |6.1.B.2| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Rear Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Reversing lamp does not emit a steady white light on all the time |4.6.2 |a|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner panel by brake servo / washer bottle |6.1.1 |c| |i|| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Nearside Front Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Battery carrier area (6.1.1 (c) (i)) | 1 |
| Registration plate issues | 1 |
| Nearside Front Outer Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Offside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Rear brake disc contaminated by oil |3.5.1h| | 1 |
| Nearside Front Inner Front passenger door catch deteriorated so the door cannot be readily opened or closed |6.2.B.2| | 1 |
| Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
| Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Nearside Steering rack insecure |2.2.B.1a| | 1 |
| Offside Front Fuel tank leaking |6.7.1a| | 1 |
| Fuel system component leaking |6.7.1a| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Brake load sensing valve linkage defective and function impaired missing (1.1.17 (a)) | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Headlamp insecure |4.1.1 |c|| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Front front brake binding |3.7.B.1| | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Body has excessive displacement which may lead to loss of vehicle control |6.1.B.1a| | 1 |
| Rear Brake load sensing valve seized |3.6.E.3| | 1 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Front Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Emissions not tested (8.2.2.2 (e)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Power steering component leaking (2.1.5 (a)) | 1 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Upper Body component corroded and likely to cause injury inner wing chassis section corroded (6.2.1 (a) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Brake cable insecure (1.1.15 (c)) | 1 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Rear Brake load sensing valve seized and ABS not fitted or inoperative and linkage (1.1.17 (c) (ii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Electrical wiring insecure and in contact with sharp edges (4.11 (a) (ii)) | 1 |