Most common failures | No# failures |
---|
Brake pipe excessively corroded | 20 |
Windscreen wiper does not clear the windscreen effectively | 10 |
Service brake: efficiency below requirements |3.7.B.7| | 7 |
Parking brake: efficiency below requirements |3.7.B.7| | 7 |
Brakes imbalanced across an axle | 7 |
Headlamp aim out of alignment | 6 |
Registration plate lamp issues | 5 |
Rear parking brake recording little or no effort | 4 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
Indicator switch faulty |1.4.A.1| | 2 |
Mechanical brake component has restricted free movement | 2 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 2 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Rear Upper Stop lamp not working |1.2.1b| | 2 |
Fuel tank insecure |7.2.1| | 2 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Brake pipe at imminent risk of failure or fracture |1.1.11 |a|| | 1 |
Nearside Front Outline marker lamp not working |4.2.1 |a|| | 1 |
Brake performance not tested |1.2.1 |g|| | 1 |
Nearside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Front Brake pipe leaking on a hydraulic braking system inner wheel arch |1.1.11 |b| |ii|| | 1 |
Offside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
Exhaust has a major leak of exhaust gases front pipe holed by flexi section |6.1.2 |a|| | 1 |
Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
Nearside Front Sub-frame fractured lower panel split |5.3.3 |b| |ii|| | 1 |
Nearside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Seat belt anchorage prescribed area strength or continuity significantly reduced under cab rear outrigger |7.1.1 |a| |i|| | 1 |
Horn not working |1.6.2a| | 1 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Power steering component|s| leaking |2.3.3b| | 1 |
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Subframe (5.3.6 (a) (i)) | 1 |
Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Rear Exhaust has a major leak of exhaust gases silencer (6.1.2 (a)) | 1 |
Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Direction indicator incomplete |1.5.A1b| | 1 |
Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Nearside Front Upper Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected sub frame mounting |5.3.6 |a| |ii|| | 1 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
Offside Rear Outer Valve stem seriously damaged |4.1.D.1e| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Nearside Front Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear brake binding | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
Fuel system component insecure |7.2.1| | 1 |
Offside Rear fog lamp not working |1.3.2b| | 1 |
Front brake application uneven | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Offside Front Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance dim/black |1.1.A.3d| | 1 |
Offside Rear brake caliper securing device loose |3.5.1j| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt wishbone |2.4.G.2| | 1 |
Nearside Rear Inner Suspension spring mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Brake hose excessively deteriorated | 1 |
Offside Front Brake pipe leaking |3.6.A.1| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Parking brake mechanism/associated mounting prescribed area is excessively corroded crossmember |3.1.9| | 1 |
Headlamp switch faulty |1.7.1| | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Upper Stop lamp not working |1.2.1b| | 1 |
Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
Offside Rear Anti-roll bar attachment bracket/mounting missing (5.3.3 (a) (ii)) | 1 |
Windscreen wiper not working Both |3.4 |a|| | 1 |
Exhaust emissions likely to be affected by an exhaust leak silencer tail pipe no longer attached to silencer. |8.2.2.1 |b|| | 1 |
Nearside Rear Lower Stop lamp not working |1.2.1b| | 1 |
Rear Brake linkage has restricted free movement load sensor pivot |3.5.1k| | 1 |
Rear Brake linkage excessively worn and seriously weakened load sensing link detached and worn |3.5.1e| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings cab to chassis mounting |6.1.B.2| | 1 |
Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Rear Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Upper Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Nearside Rear Upper Outline marker lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Brake load sensing valve linkage defective and function impaired spring broken (1.1.17 (a)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Outline marker lamp not working |4.2.1 |a|| | 1 |
Nearside Rear Outline marker lamp not working |4.2.1 |a|| | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |