| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 20 |
| Headlamp aim out of alignment | 16 |
| Service brake: efficiency below requirements |3.7.B.7| | 13 |
| Parking brake: efficiency below requirements |3.7.B.7| | 11 |
| Registration plate lamp issues | 11 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Brake hose excessively deteriorated | 4 |
| Windscreen has damage | 3 |
| Horn not working |1.6.2a| | 3 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Battery insecure |1.9.1| | 2 |
| Fuel tank insecure |7.2.1| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Rear brake binding | 2 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 2 |
| Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Outer Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Outer Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner wing |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner wing |6.2.2 |d| |i|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Rear Brake load sensing valve seized but ABS functioning |1.1.17 |c| |i|| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Parking brake not fitted on at least two wheels |3.1.1| | 1 |
| Offside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Central Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| rear brake recording little or no effort rear brakes reading 160 ns and 120 os |3.7.B.5a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Rear Rear position lamp|s| not in a clean condition and function impaired |1.1.4a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Centre Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Outer Rear Road wheel badly damaged |4.2.A.1a| | 1 |
| Front Power steering pipe|s| or hose|s| fouling other parts of the vehicle |2.3.2| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Seat belt anchorage prescribed area strength or continuity significantly reduced both front cab floors corroded |7.1.1 |a| |i|| | 1 |
| Seat belt anchorage prescribed area strength or continuity significantly reduced both front doorsteps corroded |7.1.1 |a| |i|| | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Lower Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front Lower Suspension arm attachment bracket/mounting damaged and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Lower Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Lower Suspension arm attachment bracket/mounting damaged and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt not missing but deteriorated |2.1.3 |g| |ii|| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing |5.3.6 |a| |i|| | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing area |5.3.6 |a| |i|| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Front Body insecure and dangerous to other road users cab offside rear body mount rubber bush worn . |6.1.B.1b| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings out rigger |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outrigger |6.1.B.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Lower Brake hose twisted |3.6.B.4c| | 1 |
| Brake hose has insufficient room to move | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Oil leaking continuously from engine posing a serious risk to road safety (8.4.1 (a) (ii)) | 1 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner wing (6.1.1 (c) (i)) | 1 |
| Offside Rear Floor excessively deteriorated (6.2.4 (a) (i)) | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Inner Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Inner Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill below side door / ramp |6.1.B.2| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded inner sill / outrigger |5.2.6| | 1 |
| Offside Front Inner Seat belt anchorage prescribed area is excessively corroded sill / outrigger |5.2.6| | 1 |
| Nearside Front Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings arch |6.1.B.2| | 1 |
| Offside Front Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings arch |6.1.B.2| | 1 |
| Brake performance not tested due to such low effort on rear brakes |3.7.A.1| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Upper Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Nearside Inner Front Upper Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Electrical wiring insulation so damaged or deteriorated it is likely to cause a short-circuit On battery (4.11 (c) (ii)) | 1 |
| Nearside Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Nearside Outline marker lamp not working x2 (4.2.1 (a) (ii)) | 1 |
| Offside Outline marker lamp not working x1 (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| rear brake excessively fluctuating |3.7.B.3| | 1 |
| rear brake recording little or no effort both |3.7.B.5a| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded (1.1.21 (e) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting In front of rear axle
X2 (6.2.2 (d) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Behind rear axle (6.2.2 (d) (i)) | 1 |
| Electronic power steering warning lamp indicates a failure in the system |2.3.8| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Central Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Front An item not tested |Manual| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Bonnet retaining device ineffective |8.4.2| | 1 |
| Front brake application uneven | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |