| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 91 |
| Parking brake: efficiency below requirements |3.7.B.7| | 65 |
| Brake pipe excessively corroded | 61 |
| Rear parking brake recording little or no effort | 43 |
| Headlamp aim out of alignment | 33 |
| Brakes imbalanced across an axle | 32 |
| Service brake: efficiency below requirements |3.7.B.7| | 29 |
| Offside Rear fog lamp not working |1.3.2b| | 16 |
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Parking brake lever has no reserve travel |3.1.6b| | 12 |
| Brake load sensing valve linkage seized |3.6.E.3| | 10 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 9 |
| Nearside Stop lamp not working |1.2.1b| | 8 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 8 |
| Battery insecure |1.9.1| | 7 |
| Horn not working |1.6.2a| | 7 |
| Rear brake binding | 6 |
| Rear brake application uneven | 6 |
| Windscreen has damage | 6 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 6 |
| Front brake application uneven | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 5 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Rear Stop lamp not working |1.2.1b| | 5 |
| Offside Headlamp not working on main beam |1.7.5a| | 4 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Brake load sensing valve seized |3.6.E.3| | 4 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Brake load sensing valve inoperative |3.6.E.3| | 4 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 4 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Brake hose excessively deteriorated | 4 |
| Indicator switch faulty |1.4.A.1| | 3 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Windscreen wiper blade insecure | 3 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 3 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 3 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 3 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 3 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 3 |
| Offside Upper Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 3 |
| Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 3 |
| Registration plate issues | 3 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 3 |
| Nearside Front All position lamps not working |1.1.A.3b| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Brake hose twisted |3.6.B.4c| | 2 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Bonnet retaining device ineffective |8.4.2| | 2 |
| Nearside Front Seat belt anchorage prescribed area is fractured |5.2.6| | 2 |
| Nearside Front Power steering pump leaking from a failed component |2.3.3b| | 2 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
| Brake valve leaking |3.6.A.1| | 2 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Upper Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Statutory seat belt missing |5.1.1| | 2 |
| Emissions not tested |7.0| | 2 |
| Fuel tank insecure (6.1.3 (a) (i)) | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 2 |
| Horn not working (7.7 (a)) | 2 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Headlamp switch faulty |1.7.1| | 2 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Spare wheel insecure |6.4.2| | 2 |
| Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Offside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Offside Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 2 |
| Steering system excessively tight |2.2.D.1| | 2 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Nearside Front Headlamp insecure |1.7.3| | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Nearside Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Brake performance not tested due to low rear service brake efforts |1.2.1 |g|| | 1 |
| Rear Brake load sensing valve seized |3.6.E.3| | 1 |
| Steering column universal joint has excessive play |2.1.5| | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Rear Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Rear brake disc contaminated by oil |3.5.1h| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Lower Steering column universal joint has excessive play uj in side vehicle |2.1.5| | 1 |
| Rear Brake valve leaking |3.6.A.1| | 1 |
| Nearside Front Lower Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Nearside Front Lower Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Rear Brake pipe leaking at joint |3.6.A.1| | 1 |
| Nearside Rear Upper Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Upper Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Offside Front Steering system lock to lock check twists a brake hose |2.2.D.2b| | 1 |
| Offside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Front Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Offside Front Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Shock absorber insecure |2.7.2b| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Front Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Brake rod insecure |3.5.1d| | 1 |
| Nearside Rear Direction indicator obviously incorrectly positioned |1.4.A.2b| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 1 |
| Towbar component excessively damaged |6.6.1| | 1 |
| Nearside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Position lamp light intensity significantly reduced lens has product on lens |4.2.3 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases front pipe split |6.1.2 |a|| | 1 |
| Offside Rear Brake disc contaminated rear hub leaking on to disc |1.1.14 |b|| | 1 |
| Nearside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Front Brake hose excessively twisted |1.1.12 |b| |ii|| | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis section in inner wing holed |6.1.1 |c| |i|| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Nearside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded floor holed |5.2.6| | 1 |
| Offside Front Front suspension retaining device ineffective leaf spring rubber mount deteriorated |2.5.A.4| | 1 |
| Offside Front Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded step |5.2.6| | 1 |
| Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Fuel tank insecure tank strap corroded |7.2.1| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded inner arch
|2.4.A.3| | 1 |
| Front Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Shock absorber detached |2.7.2b| | 1 |
| Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Outer Fuel pipe union leaking chassis (6.1.3 (b) (i)) | 1 |
| Rear Brake cable damaged both sides (1.1.15 (a)) | 1 |
| Central Brake relay lever has restricted free movement sized (1.1.15 (e)) | 1 |
| Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wing (6.2.2 (d) (i)) | 1 |
| Nearside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wing (6.2.2 (d) (i)) | 1 |
| Front Electrical wiring insecure and connectors likely to become disconnected chaffing on rear shocks both sides (4.11 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced X3 patches marked in yellow (6.1.1 (c) (i)) | 1 |
| Fuel cap/sealing device missing (6.1.3 (b) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Fuel system component leaking in line fuel pump |7.2.3| | 1 |
| Nearside Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Tie bar/rod rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Headlamp switch faulty full beam |1.7.1| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Rear Leaf spring anchor bracket loose |2.4.B.6a| | 1 |
| Offside Rear Rear position lamp|s| incorrect colour lense damaged |1.1.A.3e| | 1 |
| Offside Rear Stop lamp emits other than a steady red light lense damaged |1.2.1e| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded rear inner sill |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded rear inner sill |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded inner sill areas |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded inner sill areas |2.4.A.3| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outrigger areas |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outrigger areas |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings bulkhead below servo |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner arch/floor ,multiple |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings box section near wheel arch |6.1.B.2| | 1 |
| Nearside Rear Brake valve insecurely mounted |3.6.A.2a| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Offside Front Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Centre Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear front brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside passenger door catch deteriorated so the door cannot be readily opened or closed side load door |6.2.B.2| | 1 |
| Centre Drive shaft uj which forms part of the suspension has excessive play in a universal joint propshaft u/j |2.4.G.4b| | 1 |
| Offside Rear Shock absorber detached |2.7.2b| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wheel arch inner and floor pan corroded away |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wheel arch area and floor pan rotted away |6.1.B.2| | 1 |
| Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings front and rear sills badly corroded |6.1.B.2| | 1 |
| Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings front and rear sills rotted away |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wheel arch area holed |6.1.B.2| | 1 |
| Centre Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Seat belt retracting mechanism defective |7.1.2 |e|| | 1 |
| Offside Rear Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Offside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Rear Leaf spring eye defective |anchor| |2.4.B.1b| | 1 |
| Rear Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Rear Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Brake hose damaged | 1 |
| Nearside Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Body has excessive displacement which may lead to loss of vehicle control mount bolt loose |6.1.B.1a| | 1 |
| Offside Rear Body has excessive displacement which may lead to loss of vehicle control body mounting cracked and displaced |6.1.B.1a| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Rear Brake cable has wires broken and is significantly weakened hand brake |3.5.1b| | 1 |
| Central Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Floor in such a condition it is likely to cause injury cab floor rusted & holed (6.2.4 (a) (ii)) | 1 |
| Nearside Front Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting inner wing holed (6.2.2 (d) (i)) | 1 |
| Front Headlamp not working on dipped beam both no working (4.1.1 (a) (ii)) | 1 |
| Front Side repeater not working both wing indicators not working |4.4.1 |a| |ii|| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Front Headlamp aim so that beam "kick up" is not visible on the screen nearside & offside |4.1.2 |a|| | 1 |
| Rear Brake load sensing valve seized but ABS functioning |1.1.17 |c| |i|| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Rear Anti-roll bar pin or bush excessively worn Rear roll bushes worn |5.3.4 |a| |i|| | 1 |
| Offside Front Outer Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting |6.2.2 |d| |i|| | 1 |
| Nearside Rear Lower Suspension component pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Fuel pipe leaking |7.2.3| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Rear Upper Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Shock absorber insecure |2.7.2b| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings Both sides front inner arches |6.1.B.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outrigger at rear of step |6.1.B.2| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Nearside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Offside Front Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Offside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Front Bootlid cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Rear Lower Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
| Offside Rear Lower Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Offside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Upper Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Rear Upper Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Upper Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement d bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement d bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is severely distorted outrigger |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded outrigger |2.4.A.3| | 1 |
| Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Leaf spring to axle securing nut missing |2.4.B.7b| | 1 |
| Nearside Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Offside Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Lower Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Rear of cab lower (6.2.2 (d) (i)) | 1 |
| Offside Rear Lower Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Rear lower cab (6.2.2 (d) (i)) | 1 |
| Nearside Upper Outline marker lamp does not illuminate simultaneously with the position lamps and lens damaged (4.2.2 (a)) | 1 |
| Exhaust has a major leak of exhaust gases rear box |7.1.2| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Prop shaft flexible coupling excessively deteriorated |6.1.7 |d| |i|| | 1 |
| Offside Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Offside Front Track rod end ball joint has excessive play and tie rod |2.2.B.1f| | 1 |
| Rear brake caliper has restricted free movement both |3.5.1k| | 1 |
| Nearside Front Upper Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Upper Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Emissions not tested |8.2.2.2 |e|| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor pan (7.1.1 (a) (i)) | 1 |
| Offside Front Brake prescribed area is excessively corroded inner wing (1.1.21 (e) (i)) | 1 |
| Bonnet seriously at risk of opening inadvertently (3.1 (b) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Nearside Front Outline marker lamp likely to become detached (4.2.1 (c) (ii)) | 1 |
| Nearside Rear Direction indicator lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
| Nearside Rear Position lamp has a product on the lens or light source which shows white light to the rear (4.2.3 (b) (ii)) | 1 |
| Nearside Stop lamp(s) emits other than a steady red light (4.3.3 (a) (ii)) | 1 |
| Offside Front Inner Brake master cylinder/servo mounting prescribed area is excessively corroded wing (1.1.21 (e) (i)) | 1 |
| Nearside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced wing (7.1.1 (a) (i)) | 1 |
| Steering column universal joint modification unsafe (2.1.3 (f) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Front Body component insecure bumper (6.2.1 (a) (i)) | 1 |
| Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Nearside Rear Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Nearside Front Lower Shock absorber insecure bolt |2.7.2b| | 1 |
| Nearside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp lens seriously defective (4.2.1 (b)) | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded (1.1.21 (e) (i)) | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded inner wheel arch |3.6.C.3| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded inner wheel arch |5.2.6| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Shock absorber detached |2.7.2b| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Nearside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
| Offside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |