| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 47 |
| Registration plate lamp issues | 35 |
| Brake pipe excessively corroded | 33 |
| Service brake: efficiency below requirements |3.7.B.7| | 25 |
| Rear parking brake recording little or no effort | 19 |
| Headlamp aim out of alignment | 19 |
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Brakes imbalanced across an axle | 12 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 9 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 8 |
| Registration plate issues | 7 |
| Brake hose excessively deteriorated | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Nearside Side repeater not working |1.4.A.2c| | 7 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 5 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 5 |
| Offside front brake binding |3.7.B.1| | 5 |
| Nearside Front Torsion bar excessive play at an end fixing |2.4.E.2| | 4 |
| Exhaust system not adequately supported |7.1.1| | 4 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Front brake application uneven | 3 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Windscreen has damage | 2 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Horn not working |1.6.2a| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Offside Front Torsion bar excessive play at an end fixing |2.4.E.2| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 2 |
| Offside Front Side repeater not working |1.4.A.2c| | 2 |
| Rear brake application uneven | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Front Upper Suspension rod ball joint excessively worn front ball joint link rod |5.3.4 |a| |i|| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Shock absorber insecure |2.7.2b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded floor |2.4.A.3| | 1 |
| Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Stop lamp not working both |1.2.1b| | 1 |
| Rear Direction indicator not working both |1.4.A.2c| | 1 |
| Front position lamp|s| not working both |1.1.A.3b| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Rear fog lamp has less than 50% of the light sources illuminating |1.3.2b| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front Brake pipe seriously damaged |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Rear Anti-roll bar linkage missing |2.4.G.1| | 1 |
| Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brake hose damaged | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Fuel pipe union leaking |7.2.3| | 1 |
| Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wing and floor |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering and cross member by rear shock |6.1.A.1| | 1 |
| Nearside Front Inner Vehicle structure has excessive corrosion which adversely affects braking or steering leg |6.1.A.1| | 1 |
| Offside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt upper and lower tie bar |2.4.G.2| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Offside Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Rear Lower Brake load sensing valve linkage defective and function impaired nut lose |1.1.17 |a|| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Centre Front Inner Vehicle structure has excessive corrosion which adversely affects braking or steering brake pipe/hose bracket |6.1.A.1| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting centre - chalked (6.2.2 (d) (i)) | 1 |
| Offside Front Brake prescribed area is excessively corroded (1.1.21 (e) (i)) | 1 |
| Nearside Inner Front Upper Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
| Offside Rear brake disc contaminated by oil |3.5.1h| | 1 |
| Brake warning device defective |3.3.E.1b| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Offside Inner Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Leaf spring has excessive side play at eye |shackle| |2.4.B.4| | 1 |
| Offside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Front Fuel system component insecure |7.2.1| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Rear brake binding | 1 |
| Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Rear Leaf spring splayed and action impaired |2.4.B.1c| | 1 |
| Steering column universal joint has excessive play |2.1.5| | 1 |
| Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering column flexible coupling is excessively deteriorated |2.1.5| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Brake servo leaking |3.6.C.1c| | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Front Steering rack insecure to the extent there is excessive movement at the mountings bolts loose (2.1.3 (a) (ii)) | 1 |
| Nearside Front Brake hose damaged and likely to fail cords (1.1.12 (a)) | 1 |
| Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Offside Front Suspension rod ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Rear Fuel tank insecure rear strap broken (6.1.3 (a) (i)) | 1 |
| Front Exhaust has a major leak of exhaust gases pipe cracked (6.1.2 (a)) | 1 |
| Nearside Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Side repeater insecure |1.4.A.2b| | 1 |
| Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Front Tie bar/rod ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Body has a projection caused by damage |6.1.C.1| | 1 |
| Nearside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |