| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Headlamp aim out of alignment | 7 |
| Registration plate lamp issues | 7 |
| Brakes imbalanced across an axle | 4 |
| Rear parking brake recording little or no effort | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced wheel arch as marked (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced wheel arch as marked (6.1.1 (c) (i)) | 1 |
| Nearside Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sills as marked (6.1.1 (c) (i)) | 1 |
| Offside Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill as marked (6.1.1 (c) (i)) | 1 |
| Offside Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill as marked (6.1.1 (c) (i)) | 1 |
| Offside Front Upper Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Centre Rear Towbar retaining device missing |6.6.3a| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing very large hole/ corrosion |5.3.6 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing very large hole/ corrosion |5.3.6 |a| |i|| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Brake pipe excessively corroded | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded front crossmember |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is severely distorted front crossmember |2.4.A.3| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded rear off cab |5.2.6| | 1 |
| Battery insecure |1.9.1| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Nearside Position lamp lens seriously defective |4.2.1 |b|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded inner wing |1.1.21 |e| |i|| | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner wing |6.2.2 |d| |i|| | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner wing |6.2.2 |d| |i|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill |6.2.2 |d| |i|| | 1 |
| Nearside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill |6.2.2 |d| |i|| | 1 |
| Offside Front Brake hose excessively damaged ferrule badly corroded |1.1.12 |b| |ii|| | 1 |
| Offside Front Brake hose excessively damaged brake hose ferrule corroded |1.1.12 |b| |ii|| | 1 |
| Nearside Rear Passenger`s seat insecure |6.2.6 |a| |ii|| | 1 |
| Nearside Rear Seat belt not functioning as intended insecure |7.1.2 |c|| | 1 |
| Offside Rear Seat belt likely to become detached in the event of a collision bolted to wooden panel |7.1.1 |a| |ii|| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Battery insecure |1.9.1| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Rear brake binding | 1 |
| Rear Electrical wiring insecure |1.9.2a| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front Steering system excessively rough |2.2.D.1| | 1 |
| Offside Rear Fuel system component insecure tank strap broken |7.2.1| | 1 |
| Offside Front Driver`s seat insecure loose on floor |6.2.A.1| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working centre marker lights |1.1.A.3b| | 1 |
| Offside Front Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Offside Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings inner sills |6.1.B.2| | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Front Horn not working |1.6.2a| | 1 |
| Nearside All position lamps not working side lights |1.1.A.3b| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| u/j coupling |2.2.A.1b| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Rear Fuel system component insecure tank strap broken |7.2.1| | 1 |
| Front Exhaust has a major leak of exhaust gases and rear |7.1.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
| Body insecure and dangerous to other road users bonnet wont open |6.1.B.1b| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Offside Rear Leaf spring fractured (5.3.1 (b) (i)) | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement rear bush |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement rear bush |2.4.B.2| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Driver`s airbag obviously defective |5.4.1| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |