| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 46 |
| Registration plate lamp issues | 31 |
| Brake pipe excessively corroded | 30 |
| Rear parking brake recording little or no effort | 22 |
| Windscreen wiper does not clear the windscreen effectively | 22 |
| Headlamp aim out of alignment | 15 |
| Brakes imbalanced across an axle | 13 |
| Service brake: efficiency below requirements |3.7.B.7| | 10 |
| Brake hose excessively deteriorated | 7 |
| Offside Stop lamp not working |1.2.1b| | 6 |
| Rear brake binding | 6 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Rear brake application uneven | 5 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 4 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Registration plate issues | 4 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 4 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 3 |
| Offside Rear Direction indicator incomplete |1.5.A1b| | 3 |
| Nearside Side repeater not working |1.4.A.2c| | 3 |
| Fuel system component leaking |7.2.3| | 3 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Obligatory mirror insecure |8.1.1| | 2 |
| Fuel system component insecure |7.2.1| | 2 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 2 |
| Steering rack insecure |2.2.B.1a| | 2 |
| Nearside Front Upper Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Centre Statutory seat belt missing |5.1.1| | 2 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Offside Rear Direction indicator insecure |1.4.A.2b| | 2 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Upper Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Lower Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Exhaust system not adequately supported insecure |7.1.1| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Rear Electrical wiring inadequately supported |1.9.2a| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Outer Driver`s door catch deteriorated so the door cannot be readily opened or closed missing |6.2.B.2| | 1 |
| Brake servo vacuum pipe excessively chafed |3.6.C.1b| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Offside Stop lamp insecure |1.2.1a| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear Loading door cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Front Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Dropside cannot be secured in the closed position |6.4.1| | 1 |
| Offside Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Front Obligatory mirror insecure |8.1.1| | 1 |
| Offside Front Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Brake master cylinder insecurely mounted |3.6.G.1a| | 1 |
| Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Torsion bar deteriorated by corrosion so that its cross sectional area is reduced and seriously weakened |2.4.E.1b| | 1 |
| Offside Front Torsion bar deteriorated by corrosion so that its cross sectional area is reduced and seriously weakened |2.4.E.1b| | 1 |
| Centre Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Lower Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Nearside Outer Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Nearside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Side repeater not in good working order |not working| |1.5.1b| | 1 |
| Nearside Rear Leaf spring has excessive movement between a spring linkage pin and its bracket |2.4.B.3a| | 1 |
| Offside Rear Leaf spring has a spring linkage pin, excessive movement between a pin and its bracket |2.4.B.3a| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.1.B.7| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.1.B.7| | 1 |
| Nearside Rear Body has sharp edges or projections caused by corrosion or damage making the vehicle dangerous to other road users |6.5.10| | 1 |
| Transmission brake efficiency below requirements |3.8.A.9/10| | 1 |
| Front Driver`s view to front impaired by damage |6.9.1b| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Front position lamp|s| flickers when tapped lightly by hand |1.1.4c| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Nearside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Front Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Rear Loading door likely to open inadvertently or not remain closed (6.2.3 (b) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Windscreen washer not working | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Body has an unsafe modification Rust holes causing potential injury to pedestrians all around (6.2.1 (d) (i)) | 1 |
| Offside Floor excessively deteriorated Sill (6.2.4 (a) (i)) | 1 |
| Offside Floor excessively deteriorated Step (6.2.4 (a) (i)) | 1 |
| Nearside Rear Floor excessively deteriorated Sill (6.2.4 (a) (i)) | 1 |
| Offside Rear Floor excessively deteriorated Sill (6.2.4 (a) (i)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Other passenger door cannot be opened from outside the vehicle Sliding door (6.2.3 (a)) | 1 |
| Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Rear All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Centre Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Inner Front Brake pipe leaking |3.6.A.1| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Leaf spring longitudinally displaced |2.4.B.1d| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside rear brake juddering severely |3.7.A.5b| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Towbar locking device inadequate |6.6.3b| | 1 |
| Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Front brake application uneven | 1 |
| Exhaust has a major leak of exhaust gases Broken pipe/back box (6.1.2 (a)) | 1 |
| Fuel cap/sealing device component leaking (6.1.3 (b) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Front of inner arch (5.3.6 (a) (i)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Outer Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded inner wing (1.1.21 (e) (i)) | 1 |
| Nearside Front Brake pipe likely to become detached or damaged brake pipe and flexi insecure (1.1.11 (d) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting cab mount (6.2.2 (d) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Nearside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Nearside Front Power steering component|s| leaking Switch on resorvoir |2.3.3b| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded step in various places. Also floor panel corroded |5.2.6| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings cab |6.1.B.2| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded centre chassis section |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded centre chassis section |2.4.A.3| | 1 |
| Exhaust system not adequately supported front clamp |7.1.1| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |