| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 17 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Registration plate lamp issues | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Rear parking brake recording little or no effort | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Brakes imbalanced across an axle | 2 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Rear Leaf spring has excessive side play at eye |shackle| |2.4.B.4| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Brake load sensing valve inoperative |3.6.E.3| | 1 |
| Rear Brake cable insecure | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Rear Brake load sensing valve has been disconnected and was fitted as standard broken |3.6.E.2| | 1 |
| Rear Brake valve has an excessive discharge of oil |3.6.E.1| | 1 |
| Nearside Rear Anti-roll bar linkage fractured link broken |2.4.G.1| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassis leg |6.1.B.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded behind corner of bumper inner and outer |2.4.A.3| | 1 |
| Headlamp aim out of alignment | 1 |
| Horn not working |1.6.2a| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Crossmember corroded |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Inner sill area |6.1.B.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Headlamp incorrect colour |1.7.5b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Towbar attachment likely to become detached (6.1.6 (c) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Body mounting fixings insecure bed mountings corroded (6.2.2 (c) (i)) | 1 |
| Front Exhaust has a major leak of exhaust gases flexi (6.1.2 (a)) | 1 |
| Nearside Rear Leaf spring to axle fixing bolt insecure (5.3.1 (a) (i)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn both sides (5.3.4 (a) (i)) | 1 |
| Rear Tailgate cannot be secured in the closed position (6.2.1 (e)) | 1 |