| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 9 |
| Headlamp aim out of alignment | 5 |
| Brakes imbalanced across an axle | 4 |
| Rear brake application uneven | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Registration plate lamp issues | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Battery insecure |1.9.1| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced door step to sill both sides corroded (6.1.1 (c) (i)) | 1 |
| Offside Rear Inner Anti-roll bar attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Rear Inner Anti-roll bar attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 1 |
| Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced n/s sill to door step (6.1.1 (c) (i)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Rear brake binding | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion door |6.1.C.1| | 1 |
| Horn not working |1.6.2a| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush inner & outer on both sides |2.4.G.2| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn D bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn D bush (5.3.4 (a) (i)) | 1 |
| Nearside Rear Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Brake cable knotted (1.1.15 (a)) | 1 |
| Nearside Rear Brake cable damaged (1.1.15 (a)) | 1 |
| Nearside Front Lower Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Upper Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting steps (6.2.2 (d) (i)) | 1 |
| Offside Rear Brake hose leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Brake hose leaking on a hydraulic braking system |1.1.12 |c| |ii|| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Exhaust has a major leak of exhaust gases Front pipe (6.1.2 (a)) | 1 |
| Nearside Rear Brake hose leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
| Offside Front Inner Brake pipe leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Front Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Front Direction indicator adversely affected by the operation of another lamp |4.4.3 |b|| | 1 |
| Rear Direction indicator adversely affected by the operation of another lamp |4.4.3 |b|| | 1 |
| Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Windscreen washer not working | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt n/s and o/s (2.1.3 (g) (ii)) | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Headlamp switch faulty Main beam does not stay on |1.7.1| | 1 |
| Nearside Outer Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
| Nearside Rear Brake hose connection leaking on a hydraulic braking system Flexi hose to calliper (1.1.12 (c) (ii)) | 1 |
| Brake reservoir fluid level decreases after several pedal applications |3.3.C.1| | 1 |
| Brake hydraulic reservoir cap missing |3.6.G.1a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Rear Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Track rod end ball joint has excessive play Both sides |2.2.B.1f| | 1 |
| Steering rack gaiter split Both sides |2.2.D.2d| | 1 |
| front brake recording little or no effort Both sides |3.7.B.5a| | 1 |
| front brake binding Both sides |3.7.B.1| | 1 |
| rear brake recording little or no effort Both sides |3.7.B.5a| | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |