Most common failures | No# failures |
---|
Windscreen wiper does not clear the windscreen effectively | 21 |
Registration plate lamp issues | 14 |
Brake pipe excessively corroded | 11 |
Service brake: efficiency below requirements |3.7.B.7| | 9 |
Brake hose excessively deteriorated | 8 |
Headlamp aim out of alignment | 6 |
Brakes imbalanced across an axle | 6 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
Windscreen washer not working | 5 |
Parking brake: efficiency below requirements |3.7.B.7| | 4 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
Rear brake binding | 4 |
Horn not working |1.6.2a| | 3 |
Stop lamp(s) all not working (4.3.1 (a) (iii)) | 3 |
Nearside front brake binding |3.7.B.1| | 3 |
Offside front brake binding |3.7.B.1| | 3 |
Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Windscreen wiper not working |3.4 |a|| | 2 |
Nearside Rear Braking system leaking |3.6.A.1| | 2 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
Rear parking brake recording little or no effort | 2 |
Nearside Front passenger seat insecure |6.2.3| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
Offside Rear fog lamp missing |1.3.2a| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt Front ball joint (2.1.3 (g) (ii)) | 1 |
Drag link end ball joint has excessive play Front ball joint (2.1.3 (b) (i)) | 1 |
Drag link end ball joint has excessive play Rear ball joint (2.1.3 (b) (i)) | 1 |
Registration plate issues | 1 |
Windscreen wiper missing Both (3.4 (a)) | 1 |
Offside Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
Offside Headlamp insecure (4.1.1 (c)) | 1 |
Side repeater not working Both (4.4.1 (a) (ii)) | 1 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
Rear Upper Outline marker lamp not working Both (4.2.1 (a) (ii)) | 1 |
Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting Step. Within 30cm of seat base (6.2.2 (d) (i)) | 1 |
Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting Step. Within 30cm of seatbase (6.2.2 (d) (i)) | 1 |
Offside Front Fuel system component leaking |7.2.3| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Anti-roll bar rubber bush deteriorated resulting in excessive movement n/s/f d rubber |2.4.G.2| | 1 |
Exhaust has a major leak of exhaust gases exhaust broken off |front section | |7.1.2| | 1 |
Emissions not tested not tested due to exhaust broken off |7.4.B.1| | 1 |
Brake hose has insufficient room to move | 1 |
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
Main beam tell-tale not working (4.9.1 (a) (ii)) | 1 |
Offside Rear Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Air/vacuum reservoir insecurely mounted |3.6.A.2a| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Nearside Obligatory mirror insecure |8.1.1| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Side repeater incomplete |1.5.A1b| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Nearside Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
Offside Brake cable locking device insecure |3.5.1l| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Nearside Front Direction indicator not in good working order |function impaired| |1.5.1b| | 1 |
Nearside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Emissions not tested |7.3.A.1| | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced seat mouting (7.1.1 (a) (i)) | 1 |
Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced front prop bearing mounting (6.1.1 (c) (i)) | 1 |
Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced spring hanger front mounting (6.1.1 (c) (i)) | 1 |
Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Emissions not tested (8.2.2.2 (e)) | 1 |
Front Sub-frame corroded and seriously weakened x 3 (5.3.3 (b) (i)) | 1 |
Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Offside Rear outline marker lamp|s| not working |1.1.B.1c| | 1 |
Lower Steering column universal joint has excessive play |2.1.4| | 1 |
Transmission brake efficiency below requirements |3.8.A.9/10| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Rear Exhaust system not adequately supported Exhaust clamp badly corroded leaving the exhaust insecure |7.1.1| | 1 |
Nearside Front Brake hose kinked |3.6.B.4b| | 1 |
Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Centre Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
Offside front brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear fog lamp not working |1.3.2b| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Offside Front All direction indicators not working (4.4.1 (a) (ii)) | 1 |
Horn not working (7.7 (a)) | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced step sill (7.1.1 (a) (i)) | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
Offside Front Suspension component mounting prescribed area excessively damaged significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively damaged significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
Offside Front Brake pipe leaking |3.6.A.1| | 1 |
Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
Nearside Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill |6.2.2 |d| |i|| | 1 |
Centre Front Statutory seat belt missing |5.1.1| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Windscreen has damage | 1 |
Centre Rear Rear reflector excessively deteriorated so that its function is impaired |1.5.1c| | 1 |
Nearside Windscreen wiper not working (3.4 (a)) | 1 |
Offside Windscreen wiper not working (3.4 (a)) | 1 |
Nearside Rear Position lamp likely to become detached (4.2.1 (c) (ii)) | 1 |
Nearside Rear Direction indicator likely to become detached (4.4.1 (c) (ii)) | 1 |
Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Nearside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Rear An item not tested |Manual| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear Electrical wiring damaged, likely to cause a short |1.9.2b| | 1 |
Steering column cracked and unserviceable |2.2.C.1d| | 1 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |