Most common failures | No# failures |
---|
Headlamp aim out of alignment | 46 |
Brake pipe excessively corroded | 26 |
Registration plate lamp issues | 24 |
Windscreen wiper does not clear the windscreen effectively | 14 |
Parking brake: efficiency below requirements |3.7.B.7| | 9 |
Offside Rear fog lamp not working |1.3.2b| | 8 |
Service brake: efficiency below requirements |3.7.B.7| | 7 |
Brake hose excessively deteriorated | 6 |
Rear brake application uneven | 6 |
Rear parking brake recording little or no effort | 5 |
Brakes imbalanced across an axle | 5 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 4 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 4 |
Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Front brake application uneven | 4 |
Parking brake lever has no reserve travel |3.1.6b| | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Offside front brake binding |3.7.B.1| | 3 |
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Indicator switch faulty |1.4.A.1| | 2 |
Rear fog lamp not working |1.3.2b| | 2 |
Windscreen has damage | 2 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
Offside Rear All outline marker lamps not working |1.1.B.1c| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Headlamp insecure |1.7.3| | 2 |
Battery insecure |1.9.1| | 2 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
Driving control|s| clutch pedal anti-slip provision worn smooth. |6.8.3| | 2 |
Nearside Body has sharp edges or projections caused by corrosion or damage making the vehicle dangerous to other road users |6.5.10| | 2 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Offside Rear position lamp|s| not in good working order |not working| |1.1.4a| | 2 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Rear brake binding | 2 |
Nearside Rear Anti-roll bar linkage corroded and seriously weakened |2.4.G.1| | 2 |
Offside Rear Anti-roll bar linkage corroded and seriously weakened |2.4.G.1| | 2 |
Nearside Rear Brake pipe excessively chafed |3.6.B.2c| | 2 |
Fuel system component leaking |6.7.1a| | 2 |
Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Front All outline marker lamps not working |1.1.B.1c| | 1 |
Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear reflector missing |1.5.1a| | 1 |
Nearside Lower Body has a projection caused by damage |6.1.C.1| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Offside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Inner Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Outer Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Inner Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Outer Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Horn not working |1.6.2a| | 1 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
Nearside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Offside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Nearside Rear All outline marker lamps do not illuminate simultaneously with the position lamps |1.1.B.1a| | 1 |
Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 1 |
Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill x2 (6.1.1 (c) (i)) | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded outter sill front of wheel arch . | need to be fully wielded and NO under seal or sealer for test | |5.2.6| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded outter sill rear of wheel arch . | need to be fully wielded and NO under seal or sealer for test | |5.2.6| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded front of wheel arch outer sill . | need to be fully wielded and NO under seal or sealer for test | |5.2.6| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded rear leaf spring mount area. body mount area corroded . | need to be fully wielded and NO under seal or sealer for test | |2.4.A.3| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded body mount not fully wielded .body mount area corroded . | need to be fully wielded and NO under seal or sealer for test | |2.4.A.3| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded inner sill |as marked | |5.2.6| | 1 |
Nearside Headlamp not in good working order affecting the beam image |1.2.4a| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded outer sill, as marked |5.2.6| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded outer sill, as marked ,rear of wheel arch |5.2.6| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded outer sill, as marked |5.2.6| | 1 |
rear parking |secondary| brakes imbalanced | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded bulk head |3.6.C.3| | 1 |
Offside Front Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
Fuel pipe leaking |7.2.3| | 1 |
Nearside Obligatory mirror insecure |8.1.1| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Offside Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Anti-lock braking system warning lamp indicates an ABS fault | 1 |
Headlamp switch faulty |1.7.1| | 1 |
Nearside Rear Leaf spring eye defective |anchor| |2.4.B.1b| | 1 |
Offside Rear Leaf spring eye defective |anchor| |2.4.B.1b| | 1 |
Nearside Rear Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
Offside Rear Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outrigger (5.3.6 (a) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outrigger (5.3.6 (a) (i)) | 1 |
Nearside Front Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt bottom arm to chassis |2.4.G.2| | 1 |
Offside Front Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt bottom arm to chassis |2.4.G.2| | 1 |
Offside Parking brake recording little or no effort |3.7.D.3a| | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Rear fog lamp switch faulty |1.3.1a| | 1 |
Leaf spring anchor pin or bush excessively worn Both Rear Rear Bushes |5.3.4 |a| |i|| | 1 |
Front Driver`s view to front impaired by damage |6.9.1b| | 1 |
Nearside Windscreen wiper blade deteriorated |6.1.2| | 1 |
Offside Windscreen wiper blade deteriorated |6.1.2| | 1 |
Driver`s view to front impaired by crack |6.9.1b| | 1 |
Transmission brake efficiency below requirements |3.8.A.9/10| | 1 |
Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced under arch (6.1.1 (c) (i)) | 1 |
Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced under arch (6.1.1 (c) (i)) | 1 |
Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 1 |
Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 1 |
Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill near back panel (6.1.1 (c) (i)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Front Service brake lagging in operation (1.2.1 (d)) | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Emissions not tested |7.0| | 1 |
Offside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Centre Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Offside Fuel tank insecure |7.2.1| | 1 |
Offside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Power steering component|s| leaking |2.3.3b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Nearside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Offside front brake binding |3.8.A2a| | 1 |
Offside Rear Rear position lamp|s| not in a clean condition and function impaired |1.1.4a| | 1 |
Offside Rear reflector more than 50% obscured |1.4.2c| | 1 |
Nearside front brake binding |3.8.A2a| | 1 |
Nearside Seat belt retracting mechanism defective |5.1.B.6b| | 1 |
Offside Rear Body has sharp edges or projections caused by corrosion or damage making the vehicle dangerous to other road users |6.5.10| | 1 |
Offside Brake pipe excessively chafed |3.6.B.2c| | 1 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Nearside Rear Direction indicator incorrect colour |1.5.1d| | 1 |
Rear Direction indicator incorrect colour |1.5.1d| | 1 |
Nearside Rear Leaf spring has a deteriorated shackle rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Driving control|s| clutch pedal anti-slip provision loose |6.8.3| | 1 |
Nearside Front Passenger door does not latch securely closed |6.5.11b| | 1 |
Nearside Headlamp insecure |1.2.4b| | 1 |
Nearside Front brake caliper securing device loose |3.5.1j| | 1 |
Nearside Front front brake binding |3.8.A2a| | 1 |
Offside Front front brake binding |3.8.A2a| | 1 |
Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Power steering component insecure reservoir (2.1.5 (d) (i)) | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wing panel |6.1.B.2| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wing panel |6.1.B.2| | 1 |
Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Nearside Rear Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
Offside Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Rear Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
Offside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement torsion bar rubber |2.4.G.2| | 1 |
Offside Front Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement torsion bar rubber |2.4.G.2| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Rear Emergency exit door does not latch securely closed |6.2.D.1b| | 1 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Brake pipe leaking on a hydraulic braking system to flexible pipe |1.1.11 |b| |ii|| | 1 |
Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
Nearside Front All position lamps not working |1.1.A.3b| | 1 |
Offside Front All position lamps not working |1.1.A.3b| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Rear Shock absorbers damaged to the extent that it does not function |5.3.2 |b|| | 1 |
Nearside Rear Shock absorber detached |2.7.2b| | 1 |
Offside Stop lamp not working |1.3.2a| | 1 |
Offside Rear Direction indicator not in good working order |not working| |1.5.1b| | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Front Power steering pipe|s| or hose|s| fouling other parts of the vehicle chaffing on sump |2.3.2| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Fuel tank insecure |7.2.1| | 1 |
Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Bonnet retaining device ineffective |8.4.2| | 1 |
Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
Main beam `tell-tale` not working |1.7.4c| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Rear Leaf spring has a deteriorated shackle rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Brake hose has insufficient room to move | 1 |
Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wheel arche (6.2.2 (d) (i)) | 1 |
Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wheel arch (6.2.2 (d) (i)) | 1 |
Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting outriggers front to back (6.2.2 (d) (i)) | 1 |
Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting outriggers front to back (6.2.2 (d) (i)) | 1 |
Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting lower wheel arch/sill (6.2.2 (d) (i)) | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
Exhaust fumes entering the passenger area tail pipe holed |7.1.5| | 1 |
Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill |6.2.2 |d| |i|| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded inner wing panel holed |3.6.C.3| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded body floor holed |5.2.6| | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Brake load sensing valve seized |3.6.E.3| | 1 |