| Most common failures | No# failures |
|---|
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Rotten under passenger seat |6.1.B.2| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Exhaust system not adequately supported Back box hanging off |7.1.1| | 1 |
| Horn not working |1.6.2a| | 1 |
| Windscreen washer not working | 1 |
| Rear Braking system leaking |1.1.3 |d|| | 1 |
| Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt rear most gator |2.1.3 |g| |ii|| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Electrical wiring insulation in such a condition there is an imminent risk of fire or formation of sparks at battery |4.11 |c| |iii|| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is inadequately repaired anchor point on cab |7.1.1 |a| |i|| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Nearside Front Outer Seat belt not functioning as intended retractable reel missing |not able to adjust| |7.1.2 |c|| | 1 |
| Central Rear Electrical wiring insulation in such a condition there is an imminent risk of fire or formation of sparks inside cab roof |4.11 |c| |iii|| | 1 |
| Nearside Front Lower Anti-roll bar synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Registration plate lamp issues | 1 |
| Registration plate issues | 1 |
| Nearside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Severe corrosion beside drivers seat |6.1.B.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Headlamp aim out of alignment | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Front passenger seat insecure |6.2.3| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Inner Brake valve has an excessive discharge of oil |3.6.E.1| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Holed beside passenger seat |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Rotten under drivers seat |6.1.B.2| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |