| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Brake pipe excessively corroded | 11 |
| Registration plate lamp issues | 7 |
| Rear parking brake recording little or no effort | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
| Registration plate issues | 5 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Brake hose excessively deteriorated | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 2 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Inner Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Offside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Nearside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear brake caliper securing device loose |3.5.1j| | 1 |
| Offside Front Obligatory mirror not clearly visible from the drivers seat or incapable of being adjusted to be clearly visible from the driver`s seat |8.1.1d| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.2| | 1 |
| Nearside Front Body insecure to the extent that stability is seriously impaired (6.2.2 (a) (ii)) | 1 |
| Offside Front Body insecure to the extent that stability is seriously impaired (6.2.2 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Steering pivot point has excessive play n/s drop arm |2.2.B.1g| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust emits excessive smoke or vapour likely to obscure the vision of other road users (8.2.2.2 (c)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Central Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Emissions not tested |8.2.2.2 |e|| | 1 |
| Offside Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Nearside Outer Stop lamp not working |1.2.1b| | 1 |
| Offside Outer Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Obligatory mirror missing |8.1.1| | 1 |
| Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Front Steering box has excessive free play detected at the steering wheel (steering box fitted) (2.3 (a) (i)) | 1 |
| Emissions unable to be completed Exhaust is broken. (8.2.2.2 (e)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Fluid leak harmful to the environment or a risk to other road users Fuel leak from pipe. (8.4.1 (a) (i)) | 1 |
| Rear Fuel pipe leaking Above axle. Fuel leak from rusted pipe. (6.1.3 (b) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Rear of undersill rusted and holed. (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Rear of undersill rusted and holed. (5.3.6 (a) (i)) | 1 |
| Offside Front Steering box has relative movement between sector shaft and the drop arm (2.1.3 (a) (i)) | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Brakes imbalanced across an axle | 1 |