| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 56 |
| Windscreen wiper does not clear the windscreen effectively | 38 |
| Headlamp aim out of alignment | 37 |
| Registration plate lamp issues | 27 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 12 |
| Anti-lock braking system warning lamp indicates an ABS fault | 12 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 11 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 9 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 8 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 8 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 7 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 7 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 7 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 6 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Brakes imbalanced across an axle | 6 |
| Windscreen washer not working | 5 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 5 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 5 |
| Rear Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 5 |
| Registration plate issues | 5 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 4 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 4 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 4 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 3 |
| Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 3 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Rear Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 2 |
| Centre Rear Statutory seat belt missing |5.1.1| | 2 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Headlamp aim unable to be tested (4.1.2 (b)) | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Exhaust emissions exceed default limit of 1.5m-1 (8.2.2.2 (b)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Front Upper Shock absorbers has an excessively worn bush (5.3.2 (c)) | 2 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Offside Rear Shock absorbers has a serious fluid leak | 2 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Rear Sub-frame corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 2 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Offside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Insecure (6.1.7 (g) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn D Bush (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn D Bush (5.3.4 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release anchour jammed under rear seat |5.2.5a| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside front brake binding also squealing |3.7.B.1| | 1 |
| Power steering fluid reservoir empty (2.1.5 (b) (ii)) | 1 |
| Power steering inoperative (2.1.5 (c) (i)) | 1 |
| Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Exhaust emissions exceed manufacturers specified limit 0.76 (8.2.2.2 (a)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Emissions not tested (8.2.2.2 (e)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Macpherson strut attachment bracket/mounting insecure and impairing directional stability (5.3.3 (a) (ii)) | 1 |
| Offside Front Upper Macpherson strut attachment bracket/mounting insecure and impairing directional stability (5.3.3 (a) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Driver`s airbag obviously defective |5.4.1| | 1 |
| Offside Front Headlamp has a product on the light source so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Exhaust emits an excessive level of metered smoke |7.4.B.3a| | 1 |
| Power steering pump leaking |2.1.5 |a|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect lens requires polishing (4.1.2 (c)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Upper Macpherson strut mounting fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i)) | 1 |
| Offside Front Macpherson strut likely to become detached top mount broke |5.3.3 |a| |ii|| | 1 |
| Nearside Rear Brake pipe connection leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Drive shaft joint excessively worn |6.1.7 |c| |i|| | 1 |
| Nearside Rear Integral body structure has excessive corrosion which adversely affects braking or steering wheel arch (6.1.1 (c) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Power steering malfunctioning (2.1.5 (a)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Upper Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Battery leaking electrolyte |1.9.1| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Macpherson strut pin or bush likely to become detached Top mount (5.3.4 (a) (ii)) | 1 |
| Nearside Front Drag link end ball joint has excessive play drumstick (2.1.3 (b) (i)) | 1 |
| Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Nearside Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Lower Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Outer Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Prop shaft joint constant velocity boot no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Drive shaft which forms part of the suspension coupling gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Stop lamp|s| light intensity significantly reduced |4.3.3 |a| |ii|| | 1 |
| Anti-lock braking system warning lamp does not illuminate Taped over ! |1.6 |a|| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Axle deformed and unserviceable (5.1.1 (a)) | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Offside Front Electrical wiring damaged, likely to cause a short |1.9.2b| | 1 |
| Front engine mounting bracket damaged and likely to fail |6.1.D.1b| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Front brake application uneven | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Power steering pipe|s| or hose|s| fouling other parts of the vehicle |2.3.2| | 1 |
| Macpherson strut mounting likely to fail both front (5.3.3 (b) (ii)) | 1 |
| Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt ns (6.1.7 (g) (ii)) | 1 |
| Subframe mounting prescribed area excessively corroded significantly reducing structural strength front (5.3.6 (a) (i)) | 1 |
| Anti-lock braking system wiring excessively damaged osf abs ring broken (1.6 (d)) | 1 |
| Subframe mounting prescribed area excessively corroded significantly reducing structural strength rear (5.3.6 (a) (i)) | 1 |
| Nearside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| steering rack end |2.2.A.1b| | 1 |
| Offside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Drivers seat insecure Front seat bolt missing (6.2.5 (a) (ii)) | 1 |
| Front Sub-frame corroded and seriously weakened in 2 places (5.3.3 (b) (i)) | 1 |
| Drivers view of the road through the swept area of the windscreen materially affected by an obstruction Items hanging from mirror (3.1 (a) (ii)) | 1 |
| Nearside Front Shock absorber insecure |2.7.2b| | 1 |
| Offside Front Shock absorber insecure |2.7.2b| | 1 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 1 |
| Front Anti-roll bar linkage pin or bush excessively worn both sides (5.3.4 (a) (i)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn both sides deep bushes (5.3.4 (a) (i)) | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Rear Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Seat belt retracting mechanism defective |7.1.2 |e|| | 1 |
| Rear Subframe mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected |5.3.6 |a| |ii|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Offside Undertray likely to become detached inner wheel arch |6.2.1 |a| |ii|| | 1 |
| Offside Front Track rod end ball joint has excessive play and boot is split (2.1.3 (b) (i)) | 1 |
| Offside Headlamp not working on dipped beam main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Rear Sub-frame has excessive corrosion which adversely affects braking or steering (6.1.1 (c) (ii)) | 1 |
| Nearside Front Macpherson strut attachment bracket/mounting likely to become detached (5.3.3 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Fuel tank leaking excessively or a risk of fire (6.1.3 (b) (ii)) | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Service brake grabbing severely (1.2.1 (c)) | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Macpherson strut has excessive movement in the upper support bearing assembly |2.5.B.1b| | 1 |
| Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt n/s + o/s (6.1.7 (g) (ii)) | 1 |
| Offside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Rear Sub-frame has excessive corrosion which adversely affects braking or steering Rear axle. (6.1.1 (c) (ii)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Headlamp aim unable to be tested dip not working + no pattern n/s (4.1.2 (b)) | 1 |
| Offside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Body component damaged and likely to cause injury door strip missing and damaged leaving sharp edges (6.2.1 (a) (i)) | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Headlamp aim not tested |4.1.2 |b|| | 1 |
| Offside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded subframe |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded subframe |2.4.A.3| | 1 |
| Rear Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt split gaiter (2.1.3 (g) (ii)) | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Front Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Front Outer Prop shaft joint constant velocity boot no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Track rod end ball joint worn to the extent there is a serious risk of detachment |2.1.3 |b| |ii|| | 1 |
| Offside Front Macpherson strut attachment bracket/mounting insecure and impairing directional stability Upper mount collapsed |5.3.3 |a| |ii|| | 1 |
| Rear Sub-frame corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Headlamp not working on dipped beam both sides |1.7.5a| | 1 |
| Offside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear brake binding | 1 |
| Offside Front Macpherson strut likely to become detached (5.3.3 (a) (ii)) | 1 |
| Nearside Steering rack has excessive free play detected at the steering wheel |steering rack fitted| tie rod |2.3 |a| |i|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |